Regency Zero Clearance Direct Vent Gas Fireplace P36-LP4 - Manual (Page 3)

FPI P36-4 Zero Clearance Direct Vent Gas Fireplace 3
TABLE OF CONTENTS
NOTE: All installation instructions apply to
Regency ® & Hampton ® Series unless otherwise specifi ed.
Exterior Vent Termination Locations ............................18
4” x 6-5/8” Rigid Pipe Cross Reference Chart .............20
Rigid Pipe Venting Systems .................................22
Rigid Pipe Venting Arrangements ...............................23
Horizontal Terminations .......................................23
Vertical Terminations ...........................................26
Vertical Termination - Co-linear Flex System ...............28
Venting Arrangements - Vertical Termination ...............29
Direct Vent System (Flex) Installation Procedures ......32
High Elevation .............................................................33
Gas Line Installation ....................................................33
Pilot Adjustment ...........................................................34
Gas Pipe PressureTesting ...........................................34
Conversion from NG to LP
.................................................. 35
Optional Brick Panels ..................................................38
Log Set Installation ......................................................39
Standard Flush Door ...................................................42
Remote Control(Optional)............................................43
Wall Switch (Optional) .................................................43
Wall Thermostat (Optional) ..........................................43
Wiring Diagrams .........................................................44
Alternate Wiring Diagram For Wall Switch ..................45
OPERATING INSTRUCTIONS
Fan Installation (Optional) ...........................................47
Fan Removal ...............................................................47
Lighting Procedure ......................................................48
Shutdown Procedure ...................................................48
First Fire ......................................................................48
Aeration Adjustment ....................................................48
Normal Operating Sounds Of Gas Appliances ............48
SAFETY LABEL
Safety Label...................................................................5
REQUIREMENTS
MA Code - CO Detector.................................................6
(for the State of Massachusetts only) ............................6
INSTALLATION
Important Message ......................................................7
Before You Start ............................................................7
General Safety Information............................................7
Installation Checklist ......................................................7
Locating Your Gas Fireplace .........................................8
Manufactured Mobile Home Additional Requirements ..8
Heatwave Duct System .................................................8
Heat Release kit ............................................................8
Clearances ....................................................................9
Regency ® Clearances ..........................................10
Tripoli Screen Door Clearances ...........................10
Hampton
® Clearances .........................................10
Regency ® Series Combustible Mantel Clearances ..... 11
Hampton ® Combustible Mantel Clearances ...............12
Mantel Leg Clearances................................................13
Framing and Finishing .................................................14
Barcelona Series Framing Note ..................................15
Regency
® Tripoli Screen Door Series Framing Note ...16
Unit Assembly Prior to Installation ...............................17
Top Standoff Assembly ........................................17
Top Facing Support and Side Nailing Strips ........17
Venting Introduction .....................................................17
Venting.........................................................................19
Direct Vent System (Flex) ...................................19