Vanguard Heating UNVENTED (VENT-FREE) PROPANE/LP GAS LOG HEATER - Manual (Page 2)

2 105274
UNVENTED PROPANE/LP GAS LOG HEATER
VANGUARD FLAME-MAX ®
SAFETY
INFORMATION
DANGER: Carbon monoxide
poisoning may lead to death!
Carbon Monoxide Poisoning: Early
signs of carbon monoxide poisoning re-
semble the flu, with headaches, dizziness,
or nausea. If you have these signs, the heater
may not be working properly. Get fresh air
at once! Have heater serviced. Some people
are more affected by carbon monoxide than
others. These include pregnant women,
people with heart or lung disease or anemia,
those under the influence of alcohol, and
those at high altitudes.
Propane Gas: Propane gas is odorless. An
odor-making agent is added to the gas. The
odor helps you detect a gas leak. However,
the odor added to the gas can fade. Gas may
be present even though no odor exists.
Make certain you read and understand all
Warnings. Keep this manual for reference.
It is your guide to safe and proper operation
of this heater.
1. This appliance is only for use with the
type of gas indicated on the rating plate.
This appliance is not convertible for use
with other gases.
2. Do not place propane supply tank(s) in-
side any structure. Locate propane sup-
ply tank(s) outdoors.
3. To prevent performance problems, the
use of a propane tank of less than 100
lbs. capacity is not recommended.
WARNING ICON G 001
WARNINGS
IMPORTANT: Read this owner’s
manual carefully and completely
before trying to assemble, oper-
ate, or service this heater. Im-
proper use of this heater can cause
serious injury or death from burns,
fire, explosion, electrical shock,
and carbon monoxide poisoning.
WARNING: Any change to
this heater or its controls can be
dangerous.
4. If you smell gas
• shut off gas supply
• do not try to light any appliance
• do not touch any electrical switch; do
not use any phone in your building
• immediately call your gas supplier
from a neighbor’s phone. Follow the
gas supplier’s instructions
• if you cannot reach your gas supplier,
call the fire department
5. This heater shall not be installed in a
bedroom or bathroom unless installed
as a vented appliance (see Installing
Damper Clamp Accessory for Vented
Operation, page 10).
6. Never install the heater
• in a recreational vehicle
• where curtains, furniture, clothing, or
other flammable objects are less than
42 inches from the front, top, or sides
of the heater
• in high traffic areas
• in windy or drafty areas
7. Before installing in a solid fuel burning
fireplace, the chimney flue and firebox
must be cleaned of soot, creosote, ashes and
loose paint by a qualified chimney cleaner.
Creosote will ignite if highly heated. In-
spect chimney flue for damage. If damaged,
operate heater with flue damper closed.
8. If fireplace has glass doors, never oper-
ate this heater with glass doors closed. If
you operate heater with doors closed, heat
buildup inside fireplace will cause glass
to burst. Also if fireplace opening has
vents at the bottom, you must open the
vents before operating heater.
9. You must operate this heater with a fire-
place screen in place. Make sure fireplace
screen is closed while running heater.
10. This log heater is designed to be smoke-
less. If logs ever appear to smoke, turn off
heater and call a qualified service person.
Note: During initial operation, slight
smoking could occur due to log curing and
heater burning manufacturing residues.
11. To prevent the creation of soot, follow
the instructions in Cleaning and Main-
tenance, page 18.
12. Do not allow fans to blow directly into the
fireplace. Avoid any drafts that alter burner
flame patterns. Ceiling fans can create drafts
that alter burner flame patterns. Altered
burner patterns can cause sooting.
13. Before using furniture polish, wax, car-
pet cleaner, or similar products, turn
heater off. If heated, the vapors from
these products may create a white pow-
der residue within burner box or on ad-
jacent walls or furniture.
14. Do not use a blower insert, heat ex-
changer insert or other accessory not ap-
proved for use with this heater.
15. This heater needs fresh, outside air ven-
tilation to run properly. This heater has
an oxygen depletion sensor (ODS) pi-
lot light safety system. The ODS shuts
down the heater if not enough fresh air
is available. See Air for Combustion and
Ventilation, pages 4 through 6. If heater
keeps shutting off, see Troubleshooting,
pages 17 through 19.
16. Do not run heater
• where flammable liquids or vapors are
used or stored
• under dusty conditions
17. Do not use this heater to cook food or
burn paper or other objects.
18. Never place any objects on the heater.
19. Heater base assembly becomes very hot
when running heater. Keep children and
adults away from hot surface to avoid
burns or clothing ignition. Heater will
remain hot for a time after shutdown.
Allow surface to cool before touching.
20. Carefully supervise young children
when they are in the room with heater.
When using the hand-held remote ac-
cessory, keep selector switch in the OFF
position to prevent children from turn-
ing on burner with remote.
21. Do not use heater if any part has been
exposed to or under water. Immediately
call a qualified service technician to in-
spect the room heater and to replace any
part of the control system and any gas
control which has been under water.
22. Do not operate heater if any log is bro-
ken. Do not operate heater if a log is
chipped (dime-sized or larger).
23. Turn heater off and let cool before ser-
vicing, installing, or repairing. Make sure
the selector switch is in the OFF posi-
tion. Only a qualified service person
should install, service, or repair heater.
24. Make sure the selector switch is in the
OFF position when you are away from
home for long periods of time.
25. Operating heater above elevations of
4,500 feet could cause pilot outage.