YAZOO KKW36132 - Manual (Page 13)

13
SERVICE SERVICE SERVICE SERVICE SERVICE
WHEEL DRIVE BELT REPLACEMENT WHEEL DRIVE BELT REPLACEMENT WHEEL DRIVE BELT REPLACEMENT WHEEL DRIVE BELT REPLACEMENT WHEEL DRIVE BELT REPLACEMENT
WHEEL DRIVE BELT: If belts are worn or damaged,
wheels will not drive properly. To replace either belt,
proceed as follows:
1. Unhook brake linkage from brake band arm. Located
between the rear deck and the rear tire.
2. Unhook traction linkage from bellcrank. The traction
linkage connects the traction levers on the handle to the
bellcranks on each side of the mower. The bellcranks
are located behind the rear tires.
3. Unhook spring from belt guard. Located on the sides
of the tank support.
4. Remove belt guard.
5. Loosen bellcrank pivot and belt guard mounting
bolts, slide spacers off of bolts to gain clearance for belt
removal.
6. Remove belt.
7. To replace belt reverse the procedure and make any
needed adjustments.
AUXILARY BELT REPLACEMENT AUXILARY BELT REPLACEMENT AUXILARY BELT REPLACEMENT AUXILARY BELT REPLACEMENT AUXILARY BELT REPLACEMENT
(48" MOWERS)
(48" MOWERS) (48" MOWERS) (48" MOWERS) (48" MOWERS)
1. Loosen the auxilary belt adjusting rod. To relieve
tension on the belt. See figure 6 on page 8.
2. Remove belt guides from the center spindle.
3. Remove belt.
4. Reverse procedure for replacement. Adjust belt to
proper tension.
BLADE DRIVE BELT REPLACEMENT BLADE DRIVE BELT REPLACEMENT BLADE DRIVE BELT REPLACEMENT BLADE DRIVE BELT REPLACEMENT BLADE DRIVE BELT REPLACEMENT
(32", 36" & 48" MOWERS)
(32", 36" & 48" MOWERS) (32", 36" & 48" MOWERS) (32", 36" & 48" MOWERS) (32", 36" & 48" MOWERS)
BLADE DRIVE BELT: If the belt is worn or damaged,
blades will not drive properly. To replace this belt,
proceed as follows:
1. Close fuel tank shut-off valve and remove spark plug
wire.
2. Remove the belt cover from the mower deck.
3. Loosen the snubber bolt on the engagement idler so
belt can be removed. The engagement idler is located
on the front deck towards the rear. See figure 6 on page
8.
4. Raise the rear of mower and block up the rear tires to
gain access to the underside of rear deck.
5. Remove the rear belt shield from the underside of rear
deck.
6. Loosen the engine bolts with belt guides and rotate
them away from the engine pulley. Belt guides can be
seen in figures 4 and 5 on page 8.
7. Loosen the belt guides located around the pulleys on
the front deck. Belt guides are 5/16" bolts and must be
loosened to remove the belt.
8. Remove belt.
9. To replace belt - reverse the procedure and make
any needed adjustments to belt guides or belt tension.
TRANSMISSION BELT REPLACEMENT TRANSMISSION BELT REPLACEMENT TRANSMISSION BELT REPLACEMENT TRANSMISSION BELT REPLACEMENT TRANSMISSION BELT REPLACEMENT
(32", 36" & 48" MOWERS)
(32", 36" & 48" MOWERS) (32", 36" & 48" MOWERS) (32", 36" & 48" MOWERS) (32", 36" & 48" MOWERS)
1. Blade drive belt must be removed from engine pulley
before transmission belt can be removed. See blade
drive replacement, use steps 4, 5, and 6. Also see
figures 4 and 5 on page 8.
2. Loosen nut on the transmission idler pulley and slide
pulley in slot to relieve tension on belt.
3. Remove the belt from the transmission pulley and the
engine pulley.
4. Reverse the procedure for replacement.
WINTER STORAGE WINTER STORAGE WINTER STORAGE WINTER STORAGE WINTER STORAGE
To prepare your Yazoo/Kees mower for winter storage,
perform the routine maintenance and necessary
adjustments and record the part numbers of worn or
broken parts so they may be ordered and replaced
before the next mowing season. Use only authentic
Yazoo/Kees replacement parts to insure proper fit and
the saftey of your mower is maintained.
Treat the fuel in the tank with a fuel stablizer (such as
STA-BIL). This will minimize the formation of fuel gum
deposits during storage. Read and follow the mix ratio
on the container. Run the engine for at least 10 minutes
after adding the stablizer to bring it into the carburetor.
These few tips will help make your mower ready These few tips will help make your mower ready These few tips will help make your mower ready These few tips will help make your mower ready These few tips will help make your mower ready
when needed for the next mowing season and
when needed for the next mowing season and when needed for the next mowing season and when needed for the next mowing season and when needed for the next mowing season and
insure many years of dependable service.
insure many years of dependable service. insure many years of dependable service. insure many years of dependable service. insure many years of dependable service.