atwood Single and Dual Mount Motorized Jack System - Manual (Page 3)

3
6. Do one final visual check of the Jack(s) to be sure it is fully retracted
before moving or traveling with the trailer.
7. In case of electrical failure - raise and lower jack as follows:
Manual Override
To Manually Extend or Retract jack, use a 1/2˝ socket on Drive nut on end
of motor (
FIG 12).
Note: It takes 500 revoltutions of nut to extend/retract leveler one (1˝) inch.
ƽ
CAUTION
PERSONAL INJURY/PRODUCT DAMAGE
• Battery operated drills, 9.6V to 18V, are powerful. Hold drill with
both hands to protect your wrist. Keep loose clothing and body
parts away from drill as the reaction torque from the drill may cause
it to kick back.
• Refer to your drill manufacturer’s operation manual.
• Use a battery operated drill/drive to rotate nut counter clockwise (look-
ing from bottom end of nut ( FIG 12) to extend jack.
TIP:
If the storage battery of the trailer is charged by the tow vehicle; it will
improve the performance of the jack under very heavy loads if the tow vehi-
cle wiring harness is connected and the tow vehicle is running. This is not
required but may improve the performance in some cases.
ƽ
WARNING
PERSONAL INJURY
• Make sure the tow vehicle is in park and the emergency brake is
set when making vehicle hoop up and operating the jack.
SYSTEM PROTECTION FEATURES:
Low Voltage Protection
Low Battery indicator lights indicates voltage drop below 11.5 volts. Charge
battery or connect trailer to tow vehicle. Turn system off then back on to
clear low battery. If system “times out” and shuts off automatically, just
turning it back on will clear low battery indicator.
MAINTENANCE
1. Internal part of Jacks are permanently lubricated at the factory and do not
require any further lubrication.
2. If it is not possible to get Jack to operate freely, replace Jack.
3. At least once each usage season fully extend jacks and clean dirt and
grime from outside of inner tube. Coat entire outside of inner tube with sili-
cone spray lubricant. This will protect the finish of the inner tube and pro-
vide lubrication between the jack’s tubes. Clean dirt and grime from outer
housing.
4. Apply a good automotive polish or wax to the outer tube of the jacks to
maintain the appearance.
5. Should problems or questions arise, contact your dealer, trailer manufac-
turer or Atwood Consumer Service Department 574-264-2131.
ATWOOD LIMITED WARRANTY
HARDWARE SYSTEMS & COMPONENTS
Atwood Mobile Products warrants to the original owner of Atwood
Hardware Systems and Components that Atwood’s liability hereunder is
limited to the replacement of the product, repair of the product, or
replacement of the product with a reconditioned product at the discre-
tion of the manufacturer.
1. For two (2) years commencing with the date of purchase, Atwood will
replace or repair any Hardware System and Components that are found
to be defective by Atwood in material or workmanship.
2. In the event of a warranty claim, the original purchaser must contact the
Atwood Consumer Service Department, 1120 North Main, Elkhart, IN
46514, telephone 574-264-2131. Warranty Claim Service must be per-
formed as approved by the Atwood Consumer Service Department.
Warranty replacement Hardware Systems and Components or parts will
be furnished freight prepaid. Labor cost to repair or replace will be limit-
ed to the amount of the original purchase price of the systems and com-
ponents. The replaced warranty products or parts become the property
of Atwood Mobile Products and must be returned to the Atwood
Consumer Service Department freight prepaid, unless prior arrange-
ments have been agreed to.
3. This limited warranty is valid only when the product is applied, installed,
maintained and operated in accordance with Atwood Installation,
Maintenance and Operating instructions. Any deviation from these rec-
ommended specifications must be approved in writing by Atwood.
4. Any implied warranties are limited to the duration of this limited warran-
ty as stated above. Atwood does not assume responsibility for conse-
quential damage or loss, including loss of use of vehicle, loss of time,
inconvenience, expense for gasoline, telephone, travel, lodging, loss or
damage to personal properties, or loss of revenues. Some states do
not allow limitations on how long an implied warranty lasts or limita-
tions on consequential damages, so the above limitations may not
apply to you. This limited warranty gives you specific legal rights which
may vary from state to state.