Tuff Country 52901 - Toyota Tundra 99-03 2 leveling kit - Manual (Page 2)

For a list of all parts, please refer to the Parts
Description Page, at the end of the Installation
Manual.
Please Follow Instruction Carefully
Before installation begins, drive and check to make
sure there are no uncommon sounds and or frame
damage. Also at this time measure from the center of
the hub to the bottom of the fender well and record
measurements below.
Pre Installation Measurements:
Driver Side Front:______________________________
Passenger Side Front:__________________________
At the end of the installation take the same
measurements and compare to the pre-installation
measurements.
Post Installation Measurements:
Driver Side Front:______________________________
Passenger Side Front:__________________________
1. To begin installation, block the rear tires of the vehicle
so that the vehicle is stable and can’t roll backwards.
Safely lift the front of the vehicle and support the frame
with a pair of jack stands. Place a jack stand on both the
driver and passenger side. Next, remove the wheels and
tires from both sides.
2. Working on the driver side, remove the stock sway bar
hardware from the stock frame location and save the
stock hardware for later re-installation. Repeat procedure
on the passenger side. Special Note: Tie the stock
sway bar up and out of the way during installation.
3. Working on the driver side, remove the (3) upper stock
nuts that connect the stock strut into the stock location.
Save the stock nuts for later re-installation. Repeat
procedure on the passenger side.
4. Working on the driver side, remove the stock lower bolt
that connects the lower stock mounting point to the stock
lower strut. Remove the stock strut assembly and stock
lower bolt and set a side for later re-installation. Repeat
procedure on the passenger side.
Special Note: A strut compressor is going to be
needed to perform this installation. If you do not have
a strut compressor you may rent one from your local
Auto Parts store.
5. Working on the driver side strut assembly that was
removed from step # 4, carefully compress the stock strut
using a strut compressor. Special Note: Scribe a
reference mark on the top of the stock strut nut. This
LIMITED LIFETIME WARRENTY
Notice to all Tuff Country EZ-Ride Suspension
customers: It is your responsibility to keep your
original sales receipt! If failure should occur on any
Tuff Country EZ-Ride Suspension component, your
original sales receipt must accompany the warranted
unit to receive warranty. Warranty will be void if the
customer can not provide the original sales receipt.
Do not install a body lift in conjunction with a
suspension system. If a body lift is used in
conjunction with any Tuff Country EZ-Ride
Suspension product, your Tuff Country EZ-Ride
Suspension WARRANTY WILL BE VOID. Tuff Country
Inc. (“Tuff Country” ) suspension products are
warranted to be free from defects in material and
workmanship for life if purchased, installed and
maintained on a non-commercial vehicle; otherwise,
for a period of twelve (12) months, from the date of
purchase and installation on a commercial vehicle, or
twelve thousand (12,000) miles (which ever occurs
first). Tuff Country does not warrant or make any
representations concerning Tuff Country Products
when not installed and used strictly in accordance
with the manufacturer’s instructions for such
installation and operation and accordance with good
installation and maintenance practices of the
automotive industry. This warranty does not apply to
the cosmetic finish of Tuff Country products nor to
Tuff Country products which have been altered,
improperly installed, maintained, used or repaired, or
damaged by accident, negligence, misuse or racing.
(“Racing is used in its broadest sense, and, for
example, without regards to formalities in relation to
prizes, competition, etc.) This warranty is void if the
product is removed from the original vehicle and re-
installed on that or any other vehicle. This warranty
is exclusive and is in lieu of any implied warranty of
merchantability, fitness for a particular purpose or
other warranty of quality, whether express or implied,
except the warranty of title. All implied warranties are
limited to the duration of this warranty. The remedies
set forth in this warranty are exclusive. This warranty
excludes all labor charges or other incidental of
consequential damages. Any part or product
returned for warranty claim must be returned through
the dealer of the distributor from whom it was
purchased. Tuff Country reserves the right to
examine all parts returned to it for warranty claim to
determine whether or not any such part has failed
because of defect in material or workmanship. The
obligation of Tuff Country under this warranty shall
be limited to repairing, replacing or crediting, at its
option, any part or product found to be so defective.
Regardless of whether any part is repaired, replaced
or credited under this warranty, shipping and/or
transportation charges on the return of such product
must be prepaid by the customer under this
warranty.