AquaStar ChemStar On-line Chlorinator - Manual (Page 4)

flow to pool
flow from equipment
4
5
7
14
10
11
17
9
8
3
6
2
9
1
12
13
15
16
6
7
16
18
1 CH1007 Body
2 CH1008 O-ring, #128, viton
3 CH1005 Diverter tee
4 CH1004 3" threaded cap
5 CH1009 O-ring, #343, viton
6 CH1010 Check valve
7 CH1015 ½" MPT PVC plug
8 CH1016 2" x 1½" S x S bushing, qty 2*
9 CH1017 ½" NPT x tube fitting w/nut, qty 2
10 CH1018 ½" x short MPT nipple
11 CH1019 ½" chlorine control valve
12 CH1026 ⅝" OD chlorinator tube
13 CH1027 Tube support spring
14 CH1029 Screen**
15 CH1030 Standpipe adapter
16 CH1031 ⅝" OD 18" tube (optional top feed)
17 CH1036 #8 x ½" lg slotted hex head screw
18 CH1059 Silicone lubricant
*Not used with 2" PVC, for 1½" PVC only.
**Be sure screen has not come loose in shipment.
If loose, snap over four posts in bottom of
chlorinator to replace.
NOTE: To service check valve (6), remove
screw (17), unscrew (counter-clockwise)
chlorinator body (1) from diverter tee (3).
BROMINE STANDPIPE INSTALLATION
Do not install chlorinator into copper plumbing. Pipe damage could occur. Never install chlorinator before heater.
heater damage could occur.
You may substitute bromine tablets or sticks for trichlor in this chlorinator. Do not mix. Calcium hypochlorite is not to be used in any form.
To increase erosion of small bromine tablets, install Bromine Standpipe as follows:
Remove screen from bottom of chamber exposing check valve (6). Insert adapter (15) into check valve opening.
Cut supplied ⅝" black tube (16) to 6" length and push tube into adapter opening.
Filter Heater
Pump
Feeder
Pool / Spa
Skimmer
Typical installation with heater
Filter
Pump
Pool / Spa
Skimmer
Feeder
Typical installation without heater
technical support: (877) 768-2717
ChemStar is a trademark and/or a registered trademark of AquaStar Pool Products, Inc. and/or its affiliated
companies in the United States and/or other countries. Unless noted, names and brands of others that may
be used in this document are not used to indicate an affiliation or endorsement between the proprietors of
these names and brands and AquaStar Pool Products, Inc. Those names and brands may be the trademarks
or registered trademarks of those parties or others.
© 2013 AquaStar Pool Products, Inc.
0213
MODEL CH100 Bottom Feed Top Feed
Chamber Capacity - 1" Tablet
Quantity 98 98
Weight 3.5 lbs 3.5 lbs
Chamber Capacity - 3" Tablet
Quantity 11 11
Weight 4.8 lbs 4.8 lbs
Maximum Erosion in 24 Hours 0.67 lbs 1.75 lbs
Treat Pool/Spa Size in Gallons per 24 Hours*
@ 10 ppm 6,700 17,500
@ 5 ppm 13,400 35,000
@ 2½ ppm 26,800 70,000
Dimension 17¾" H x 5" W x 10" D 17¾" H x 5" W x 10" D
Service Clearance for Lid Removal 19" 19"
*using 1" Trichlor tabs