Vertical contact toaster, Replacement parts (continued) – A.J. Antunes & Co VCT-2000 9210310 User Manual
Page 23
23
VERTICAL CONTACT TOASTER
P/N 1010769 Rev. M 02/13
Item Part No.
Description
Qty.
1 0011266 Conveyor Belt (Incl. items below)
2
0800204 1/2” Pitch Link, Small
2
0800121 3/4” Pitch Link, Large
38
2 2150117 Idler Shaft
2
3 7000322 Conveyor Cover Assy. (Incl. #29, 52, 2
61, And 76)
4 0010475 Tensioner Assy. (Incl. #40, 76, 85)
4
5 7000644 Rod, Conveyor Cover
4
6 7000207 Sprocket w/setscrew
8
7 7000199 Spacer Kit
1
8 0011444 Control Housing Cover Assy.
1
9 2150118 Drive Shaft
2
10 2100212 Handle, Pull, Snap-in
2
11 7000739 Control Board Kit
1
12 7000397 Base Heater
1
13 0503557 Base, Outer
1
14 0503558 Base, Inner
1
15 1001023 Label, Caution HOT
1
16 7000167 Bearing & Retainer Kit
6
16A 7000224 Bearing & Retainer Kit
1
(Incl. six of #16)
16B 7000539 Bearing & Spacer Kit
1
(Incl. #11, 12 & 16)
17 2150181 Drive Sprocket
2
2150109 Drive Sprocket
2
Mfg. No. 9210301
18 2150187 Drive Chain
1
19 0011299 Idler Sprocket & Bearing
1
20 0011300 Bracket, Idler Sprocket Assy.
1
(Incl. #91, 89, 90, 19, 87)
21 0503589 Bracket, Motor Mounting
1
22 7000240 Drive Motor Kit, Dual Frequency
1
50/60 Hz (Incl. #58)
23 2150199 Sprocket w/Setscrew,
1
18 Tooth, for 60Hz.
2150211 Sprocket w/Setscrew,
1
22 Tooth, for 50 Hz.
2150120 Sprocket w/ Setscrew
1
32 Tooth, for 19 second unit
(Mfg. No. 9210120 only)
24 7000542 Rocker Switch, On/Off (250 VAC)
1
25 7000296 Ball Bearing (2-Pack)
1
26 7000652 Relay, Solid State
2
27 4010187 Transformer
1
28 7000416 Conveyor Belt Wrap (2-Pack)
1
29 7000186 Roller Tensioner Assy. (2-Pack)
1
(Incl. #52, 61 & 76)
30 0503496 Tensioner Bracket, Right
2
31 0503497 Tensioner Bracket, Left
2
32 1001006 Label, Control
1
33 1001069 Label, Dial Compression
1
34 2100253 Knob, Control
2
35 0011445 End Housing Cover Assy.
1
36 4050214 Thermocouple Platen Assy.
1
37 0021170 Weldment, End Housing
1
38 7000249 Release Sheet (3-Pack)
-
7000250 Release Sheet (10-Pack)
-
39 0021169 Control Housing
1
40 7000121 Slide Rail Kit (Includes two Slide
Rails for Tensioners & #85
2
41 0021207 Conveyor Cam
2
42 7000176 Thermocouple Retainer Kit
2
43 4030332 High Limit Control
1
44 0503544 Guard, Knob
1
45 0503455 Tension Spring, Inner
4
46 0503590 Bracket, Motor
1
47 0700580 Wire Set (not shown)
1
48 0503385 Bun Chute (Mfg. No. 9210100,
1
9210106, 9210110 & 9210120 only)
48A 0503677 Bun Chute
1
(Mfg. No. 9210102 only)
49 4030348 Auxiliary Heater, 675W/230V
2
4030349 Auxiliary Heater, 675W/208V
2
50 7000165 Auxiliary Thermocouple Kit
1
51 7000288 Platen (208V)
1
52 2100252 Tape
4
53 0503359 Bracket, Relay
1
54 0503150 Heater Clip
2
55 303P127* Hinge Pin, Belt Wrap
2
56 4060355 Terminal Block
1
57 0503533 Bracket, Auxiliary Thermocouple
1
58 4000170 Fan Blade, Motor
1
59 2180128 7/8” Hole Plug
1
60 040K251 Strain Relief (Domestic) (Incl. #63)
1
0400315 Strain Relief (International)
1
61 05P2199* Spacer
4
62 0500464 Retainer, Bearing
1
63 040P138* Locknut, 1/2”
1
64 0011528 Heat Shield Assy.
1
0012330 Heat Shield Assy. with Dampers
1
(Mfg. No. 9210304 & 122 only)
0012558 Heat Shield Assy.
1
(Mfg. No. 9210120 only)
65 325P163* Setscrew, 1/4-28 x 5/16”
8
66 1001192 Label, Caution Hot
1
67 308P183* Screw, Hex, #8-32 x 3/8”
2
68 304P105* Nut, #4-40, “KEPS”
4
69 406P107* Cable Tie
1
70 308P143* Nut, #8-32, “KEPS”
6
Item Part No.
Description
Qty.
REPLACEMENT PARTS (continued)