Document Outline

• Chapter 1 – Introduction
  • Aerial Platform Features
  • Options
  • Operator’s Manual
  • Safety Alerts
  • Operation
  • Maintenance
  • Manual of Responsibilities
  • Additional Information
• Chapter 2 – Specifications
  • Component Identification
  • Working Envelope
  • General Specifications
    • Aerial Platform
    • Platform
    • Function Speed
    • Drive System
    • Tires
    • Electrical System
    • Hydraulic System
    • Engine
    • Ambient Air Temperature Operating Range
    • Maximum Wind Speed
  • Engine Specifications
  • Engine Oil Viscosity
    • Cummins B3.3
    • General Motors 2.4L
• Chapter 3 – Safety
  • Electrocution Hazards
  • Minimum Safe Approach Distance
  • Prestart Inspection
  • Work Place Inspection and Practices
  • Operation
  • Tip-Over and Falling Hazards
  • Electrical System
  • Hydraulic System
  • Engine and Fuel Handling Precautions
  • Placards and Decals
• Chapter 4 – Safety Devices
  • Emergency Stop Controls
  • Emergency Power System
  • Emergency Bleed Down System
  • Emergency Lowering Knob
  • Axle/Boom Interlock
  • Ground Operation Switch
  • Platform Foot Switch
  • Guardrails
  • Lanyard Anchors
  • Envelope Management System
    • Height Restriction
  • Ground Fault Circuit Interrupter
  • Tilt Alarm
  • Engine Protection Systems
    • High Engine Temperature Alarm
    • Low Oil Pressure Alarm
  • Horn
  • Drive Motion Alarm
  • Flashing Light
  • Driving Lights
  • Platform Work Lights
• Chapter 5 – Gauges and Displays
  • Hour Meter
  • Engine Temperature Gauge
  • Ammeter
  • Engine Air Filter Gauge
  • Fuel
  • Engine Oil
  • Hydraulic Fluid Filter Gauge
  • Fluid Level and Temperature Gauge
• Chapter 6 – Controls
  • Battery Disconnect Switch
  • Axle Controls
  • High Range Speed Selector – 4x4
  • Lower Controls
    • Start Switch
    • Emergency Stop Button
    • Control Selector Switch
    • Ground Operation Switch
    • Boom/Axle Switch
    • Rotation Switch
    • Boom Elevation Switch
    • Boom Extension Switch
    • Boom Speed Knob
    • Jib Articulation Switch
    • Platform Level Switch
    • Platform Rotate Switch
    • Engine/Emergency Power Switch
    • Engine Speed Switch
    • Fuel Switch
    • Hydraulic System Warm-Up Switch
  • Circuit Breaker Reset Buttons
  • Upper Controls
    • Start Switch
    • Emergency Stop Button
    • Boom Joystick
    • Drive Joystick
    • Drive Range Switch
    • Jib Articulation Joystick
    • Platform Level Switch
    • Platform Rotate Switch
    • Boom Extend/Retract Joystick
    • Engine/Emergency Power Switch
    • Throttle Switch
    • Horn Button
    • Platform Foot Switch
  • Machine/Generator Switch
  • Driving and Platform Work Lights
• Chapter 7 – Prestart Inspection
  • Operator’s Manual
  • Engine
    • Oil Level
    • Coolant
    • Radiator
    • Fuel Tank
    • Fuel Line
    • Air Filter
    • Charging System
  • Electrical System
    • Battery Fluid Level
    • Battery Terminals
    • Cables and Wiring Harness
  • Hydraulic System
    • Fluid Level
    • Fluid Filter
    • Hoses, Tubes, and Fittings
  • Tires and Wheels
  • Axle/Boom Interlock
  • Lower Control Station
    • Operating Controls
    • Emergency Stop
    • Emergency Power
    • Envelope Management System
  • Emergency Lowering
  • Level Sensor
  • Flashing Light
  • Sandblast Protection Kit
  • Structures
    • Weldments
    • Slide Pads
    • Wire Ropes
    • Fasteners
  • Upper Control Station
    • Guardrail System
    • Lanyard Anchors
    • Operating Controls
    • Emergency Stop
    • Emergency Power
    • Horn
    • Electrical Power Outlet
    • Drive Motion Alarm
    • Driving and Work Lights
    • Platform Control Cover
  • Tow Kit
  • Placards and Decals
  • Prestart Inspection Checklist
• Chapter 8 – Operation
  • Cold Weather Start-Up
  • Engine Cold Weather Start Kit
    • Cummins – Block Heater
    • GM – Radiator Hose In-Line
  • Hydraulic System Cold Weather Warm-Up
    • Hydraulic System Warm-Up Switch
    • Manually Warming The Hydraulic System
  • Preparing for Operation
  • Lower Controls
  • Axle Controls
    • Extending The Rear Axles
    • Retracting The Rear Axles
  • Upper Controls
    • Boom Operation
    • Driving and Steering
    • Drive Speeds
    • Motion Warning Alarm
  • Four Wheel Drive
    • High Range Speed Selector
  • AC Generator
  • Dual Fuel
  • Air Line
  • Driving Lights
  • Platform Work Lights
• Chapter 9 – Stowing and Transporting
  • Stowing
    • Tucked Stow
  • Transporting
    • Driving
    • Winching
    • Hoisting
    • Securing for Transport
• Chapter 10 – Emergency Operation
  • Emergency Power System
    • Lower Controls
    • Upper Controls
  • Electric Emergency Bleed Down System
  • Manual Emergency Bleed Down System
  • Towing
• Chapter 11 – Troubleshooting
  • Troubleshooting Chart
• Appendix A – Glossary