JLG 40HA ANSI Parts Manual - Manual (Page 20)

1-12 3120673
SECTION 1 FRAME
S
E
C
T
I
O
N
1
F
R
A
M
E
126 4130161 Spindle (Left Side) 1
0961778 Bushing, Excel 2
127 0630425 Bolt 1"-8NC x 3 3/4" 2
128 3450606 Pin, Cotter 3/16" x 1 1/2" 1
129 3431622 Pin, Clevis 1" x 2 3/4" 1
130 Not Used
131 Not Used
132 0100011 Loctite #242 (Not Shown) A/R
133 2160003 Fitting, Grease - 45° 2
134 0560714 Block, Tie-Rod (Left Side) 1
135 3300229 Nut, Jam 1 1/4"-12NF LH (Left Side) 1
136 3450810 Pin, Cotter 1/4" x 2 1/2" 2
137 4640812 Valve, Relief (After February 1994) 2
138 3780183 O-Ring (After February 1994) 4
139 3323403 Nut, Slotted 1 1/2"-6NF (Prior to May 1994) 2
3313403 Nut, Slotted 1 1/2"-6NC (May 1994 to Present) 2
STEERING AND SPINDLES INSTALLATION - 4WD
FRONT AND ALL REAR STEER (STANDARD
PARTS) Ref.
201 4130221 Spindle (Front Right Side and Rear Left Side) 1
202 4130222 Spindle (Front Left Side and Front Right Side) 1
203 1681555 Steer Cylinder Assembly (See Section 5 for Break-
down) 1
204 3841018 Tie-Rod 1
205 0560714 Block, Tie-Rod (Left Side) 1
206 3300229 Nut, Jam 1 1/4"-12NF (Left Side) 1
207 0560605 Block, Tie-Rod (Right Side) 1
208 3323002 Nut, Jam 1 1/4"-12NF 1
209 3300175 Locknut 3
210 0440091 Bearing, Thrust 3
211 2160002 Fitting, Grease 4
212 2160003 Fitting, Grease - 45° 4
213 0440161 Bearing, Thrust 4
214 Cover Options: 4
3530244 (Prior to August 1992)
3536411 (August 1992 to Present)
215 Fastener Options: A/R
0641404 Bolt 1/4"-20NC x 1/2" (Prior to August 1992)
2080026 Stud, Drive (August 1992 to May 1994)
4300106 Stud, Drive (May 1994 to Present)
216 4761400 Lockwasher 1/4" (Prior to August 1992 Only) 8
217 3431622 Pin, Clevis 1
218 4712600 Flatwasher 1" 1
219 3450606 Pin, Cotter 3/16" x 1 1/2" 1
220 0641608 Bolt 3/8"-16NC x 1" 8
221 4751600 Flatwasher 3/8" 8
222 1380124 Clip, Retainer 8
FIGURE 1-2. FRAME, STEERING AND AXLE INSTALLATIONS - 2WD AND 4WD (WITH 4 WHEEL
STEER) (CONTINUED)
FIG & ITEM # PART NUMBER DESCRIPTION QTY. REV.