JLG 500RTS Parts Manual - Manual (Page 86)

2-38 400RTS 500RTS 3120830
SECTION 2 GROUND CONTROLS
154 0340041 2 Clamp, 2" Muffler (Prior to September 1995)
1320019 2 Clamp, 2" Muffler (September 1995 to Present)
155 4566672 1 Tube, Exhaust
156 3220095 1 Muffler, Spark Arrest
157 0901387 1 Bracket (Prior to S/N 34962)
0902382 1 Bracket (S/N 34962 to Present)
158 1320011 1 Clamp, 2 1/2" Muffler
1320011 1 Clamp, 2 1/2" Muffler (Dual Fuel) (Prior to S/N 83238)
1320021 1 Clamp, 2 1/4" Muffler (Dual Fuel) (S/N 83238 to Present)
159 1060360 1 Cable
160 0630370 2 Rod, Tie Down
161 1 Tie Down, Battery Options:
0400002 Tie Down, Battery (Prior to S/N 46528)
2910479 Clips
0400174 Tie Down, Battery (S/N 46528 to Present)
162 3300029 2 Wing Nut, 3/8"-16NC
163 1 Plate, Battery Cover Options:
3536144 Ford LRG 423 DIS (Prior to S/N 46528)
1670841 Ford LRG 425 (S/N 46528 to Present)
164 1060254 1 Cable
165 1 Battery, 12 Volt Options:
0400003 Ford LRG 423 DIS (Prior to S/N 46528)
0400075 Ford LRG 425 (S/N 46528 to Present)
166 1 Masonite Options:
3980003 Ford LRG 423 DIS (Prior to S/N 46528)
3980007 Ford LRG 425 (S/N 46528 to Present)
167 3538735 1 Plate, Exhaust Cover
168 Not Used
169 4921746 1 Wiring Harness
170 3911012 4 Screw #10-24NC x 3/4"
171 1320022 6 Clamp, Worm Gear
172 2720015 10 ft. Hose 1/4"
173 2720160 2 ft. Hose, Low Pressure 1/2"
174 2 Vacuum Cap Options:
1120342 Vacuum Cap (Prior to S/N 64796)
1120432 Vacuum Cap (S/N 64796 to Present)
175 4740185 1 Flatwasher (S/N 46528 to Present)
176 1320180 5 Clamp, Worm Gear (S/N 46528 to Present)
177 4761700 2 Lockwasher 7/16” (S/N 46528 to Present)
178 Not Used
179 2220315 1 Fitting, Straight (S/N 46528 to Present)
180 0840046 1 Boot, Battery Pos. (S/N 103576 to Present)
181 0840047 1 Boot, Battery Neg. (S/N 103576 to Present)
— — — — — — — — — —
0100020 A/R Sealant, Pipe
FIGURE 2-8. ENGINE INSTALLATION - FORD LRG-423 DIS/LRG-425 (CONTINUED)
ITEM # PART NUMBER QTY. DESCRIPTION REV.