JLG 860SJ Operator Manual - Manual (Page 9)

TABLE OF CONTENTS
3121138 – JLG Lift – iii
SECTION - PARAGRAPH, SUBJECT PAGE SECTION - PARAGRAPH, SUBJECT PAGE
REGULATOR (PRIOR TO S/N 0300134626) . . . .6-33
6.7 PROPANE FUEL FILTER REPLACEMENT. . . . . . .6-35
Removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-35
Installation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-35
6.8 PROPANE FUEL SYSTEM PRESSURE RELIEF . .6-37
6.9 SUPPLEMENTAL INFORMATION . . . . . . . . . . . . .6-37
SECTION - 7 - INSPECTION AND REPAIR LOG
LIST OF FIGURES
2-1. Basic Nomenclature - Sheet 1 of 2 . . . . . . . . . . . . .2-6
2-2. Basic Nomenclature - Sheet 2 of 2 . . . . . . . . . . . . .2-7
2-2. Daily Walk-Around Inspection - Sheet 1 of 2 . . . . . .2-8
2-3. Daily Walk-Around Inspection - Sheet 2 of 2 . . . . . .2-9
2-4. Horizontal and Capacity Limit Switches -
Sheet 1 of 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-10
2-5. Horizontal and Capacity Limit Switches -
Sheet 2 of 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-11
2-6. Limiting and Cut-Out Switches - Sheet 1 of 2 . . . .2-12
2-7. Limiting and Cut-Out Switches - Sheet 2 of 2 . . . .2-13
3-1. Ground Control Station - 800S . . . . . . . . . . . . . . . .3-3
3-1. Ground Control Station - 860SJ. . . . . . . . . . . . . . . .3-4
3-2. Ground Control Indicator Panel - Sheet 1 of 2 . . . .3-7
3-3. Ground Control Indicator Panel - Sheet 2 of 2 . . . .3-8
3-4. Platform Control Console. . . . . . . . . . . . . . . . . . . .3-11
3-5. Platform Control Console - w/Drive Orientation . . 3-12
3-6. Platform Light Panel . . . . . . . . . . . . . . . . . . . . . . . 3-18
3-7. Platform Light Panel - w/Drive Orientation . . . . . . 3-19
4-1. Position of Least Backward Stability . . . . . . . . . . . 4-3
4-2. Position of Least Forward Stability . . . . . . . . . . . . . 4-4
4-3. Grade and Side Slopes . . . . . . . . . . . . . . . . . . . . . 4-7
4-4. Drive Disconnect Hub. . . . . . . . . . . . . . . . . . . . . . 4-10
4-5. Typical 800S/860SJ Transport . . . . . . . . . . . . . . . 4-15
4-6. Lifting and Tie Down Chart . . . . . . . . . . . . . . . . . . 4-16
4-7. Decal Location - Rear Entry Platform -
Sheet 1 of 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-17
4-8. Decal Location - Rear Entry Platform -
Sheet 2 of 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-18
4-9. Decal Location - Side Entry Platform -
Sheet 1 of 5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-31
4-10. Decal Location - Side Entry Platform -
Sheet 2 of 5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-32
4-11. Decal Location - Side Entry Platform -
Sheet 3 of 5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-33
4-12. Decal Location - Side Entry Platform -
Sheet 4 of 5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-34
4-13. Decal Location - Side Entry Platform -
Sheet 5 of 5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-35
6-1. Serial Number Locations . . . . . . . . . . . . . . . . . . . 6-11
6-2. Engine Operating Temperature Specifications - Deutz
- Sheet 1 of 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-12