JLG 800A_AJ Parts Manual - Manual (Page 57)

3121629 800A 800AJ 2-27
SECTION 2 TURNTABLE
410 70004270 4 Stud, Mounting - 1001144319 Engine (CE Specs Only)
410 See Note AR Nut, Exhaust Manifold - 1001147823 Engine (All Specs except
CE Specs)
(Note: Not Available for Purchase.)
410 70003476 AR Nut, Exhaust Manifold - 1001144319 Engine (CE Specs Only)
411 70004056 1 Alternator - 1001147823 Engine (All Specs except CE Specs)
411 7000663 1 Alternator - 1001144319 Engine (CE Specs Only)
411 70001868 1 Regulator, Voltage (Not Shown)
411 70001866 1 Seal, Voltage Regulator (Not Shown)
411 70002234 1 Bar, Alternator Adjustment
412 7020479 1 Starter
412 70004058 1 Relay - 1001147823 Engine (All Specs except CE Specs)
412 7026608 1 Relay - 1001144319 Engine (CE Specs Only)
413 70004060 2 Plug- In Connector - 1001147823 Engine (All Specs except CE
Specs) (Not Shown)
413 See Note 2 Plug- In Connector - 1001144319 Engine (CE Specs Only) (Not
Shown) (Note: Not Available for Purchase.)
414 7027791 1 Transmitter, Temperature
415 7027790 1 Sensor, Oil Pressure
416 70004272 1 Sensor, Speed - 1001147823 Engine (All Specs except CE
Specs)
416 7024565 1 Sensor, Speed - 1001144319 Engine (CE Specs Only)
417 7027792 1 Throttle Actuator
417 7027276 2 Springs
418 70003475 1 Thermostat - 1001147823 Engine (All Specs except CE Specs)
(Located at rear of engine block - Not Shown)
418 7020459 1 Thermostat - 1001144319 Engine (CE Specs Only) (Located at
rear of engine block - Not Shown)
419 70001870 1 Flywheel with Ring Gear
7024579 1 Gear, Ring 110 Tooth
420 7000695 Muffler - 1001147823 Engine (Standard on All Specs except CE
Specs)
420 1001099051 Muffler - 1001144319 Engine (Standard on CE Specs Only)
(Note: Not Included with Engine - Must be Purchased Separately)
420 1001101241 Catalytic Muffler Option on ANSI Export, Australian, CE &
Japanese Specs
420 70001844 1 U-Clamp (1001147823 Engine Only)
420 7020471 1 Gasket (1001147823 Engine Only)
421 7027795 1 Module, Control
422 70001181 1 Valve (1001147823 Engine Only) (Not Shown)
423 70000345 4 Plug, Glow
424 70000800 1 Camshaft Pulley Repair Kit (Not Shown) (1001147823 Engine
Only)
425 70001847 1 Breather, Front Cover (Not Shown) (1001144319 Engine Only)
425 70001126 1 Seal, Front Cover Breather (Not Shown) (1001144319 Engine
Only)
426 70002415 1 Gasket, Head with 1 Notch (Not Shown)
426 70002416 1 Gasket, Head with 2 Notches (Not Shown)
426 70002417 1 Gasket, Head with 3 Notches (Not Shown)
427 7027796 1 Harness, Engine (Connects to Item 421)
427 70001872 1 Harness, Engine (Connects to p/n 7027796)
FIGURE 2-7. DEUTZ D2011 ENGINE INSTALLATION (CONTINUED)
ITEM # PART NUMBER QTY. DESCRIPTION REV.