JLG 740AJ Parts Manual - Manual (Page 108)

2-82 740AJ 3121652
SECTION 2 TURNTABLE
39 1001136988 1 Generator Assembly
70001100 1 Rotor (Includes p/n 70001384 & 70000863) (Not Shown)
70001384 1 Bearing, Ball Radial (Not Shown):
70000863 1 Fan (Not Shown)
70004093 1 Stator
70002297 1 Stud
7024484 NLA Brushholder Assembly (Not Shown) (Use p/n70003631)
39A 70004099 1 Key
39B 70001966 1 Bearing, Ball Radial (Located in Belt Tensioner Endbell)
39B 70003708 1 Ring, Internal Retaining (Located in Belt Tensioner Endbell)
39B 70003709 1 Ring, External Retaining (Located in Belt Tensioner Endbell)
39C 70004092 Endbell, Belt Tensioner
39D 70004094 1 Endbell, Brush Block
39E 70004096 1 Shroud
39E 70004097 1 Insulator, Endbell
39E 7027799 1 Block, Connector 6 Position (Not Shown)
39E 70002460 1 Nut, Brass (Attaches p/n 7027799 to Cover) (Not Shown)
39E 7024485 1 Breaker, Circuit 30Amp (Not Shown)
39E 70001696 1 Boot, Breaker (was p/n 7024486 - Not Shown)
39E 7026626 1 Connector, 6 Position (Includes Seal) (Not Shown - Plugs into
Item 36)
39E 7026597 1 Connector, W/Leads (Not Shown)
39E 70004098 Insulator, Endbell (Not Shown)
39E 70004095 Plate, End Panel
39E 70001974 1 Decal - Terminal Connections
39F 70001973 1 Decal - Warning Moving Parts
40 1001142643 1 Support
41 1001142646 1 Belt, Drive
42 1001157592 1 Junction Box Assembly (60Hz Specs) (See Items 101-124 for
Breakdown)
43 0641616 1 Bolt 3/8-16 x 2
44 3311005 4 Nut #10-24
50 3931628 4 Capscrew 3/8-16 x 1-3/4
51 3580320 1 Pulley
52 0771415 1 Bolt M14 x 35mm Grade 10.9
1001157592 Ref JUNCTION BOX ASSEMBLY (60HZ SPECS) A
101 1060343 1.5ft/.46m Cable, Electrical 10/4
102 1060494 2ft/61cm Cable, Electrical 10/4
103 1671092 1 Cover
104 3300396 1 Cover, Fuse
105 3311001 6 Nut #10-24
106 4360070 1 Circuit Breaker - 15 Amp
108 4460425 1 Connector, Strain Relief
109 4460426 2 Connector, Strain Relief
111 4460963 1 Connector (60Hz Spec Only)
112 4711000 4 Washer, #10
114 10702077 2 Screw #10-32 x 3/8
FIGURE 2-20. 7500W SKYPOWER GENERATOR INSTALLATION - DEUTZ ENGINE MACHINES
(CONTINUED)
ITEM # PART NUMBER QTY. DESCRIPTION REV.