JLG E45A_AJ Parts Manual - Manual (Page 38)

1-32 3120885
SECTION 1 FRAME
S
E
C
T
I
O
N
1
F
R
A
M
E
50 1060731 Cable, Battery (Includes Terminal Boot) (– Battery to
Ground) 1
51 1060730 Cable, Battery (Includes Terminal Boot) (+ Battery to
Starter) 1
52 Not Used
53 0461406 Bolt 1/4”-20NC x 3/4” 4
54 4711400 Flatwasher 1/4” Narrow 8
55 3311405 Locknut 1/4”-20NC 4
56 Not Used
57 Not Used
58 Not Used
59 4060803 Flex-Trim 16in/4.9m
60 3960417 Seal 28in/
71cm
61 4100025 Sleeve, Fiberglass 26in/
66cm
62 4920385 Wire, Safety 7in/18cm
63 2820112 Insulation 2
64 2820116 Insulation (Right Side) 1
65 2820116 Insulation (Left Side) 1
66 2720455 Hose 1
67 1320012 Clamp 2
68 0259481 Plenum Box Assembly 1
69 3960418 Seal 3ft/.9m
70 4922319 Harness, Generator (Not Shown - See Section 7 for
Breakdown) 1
71 4460267 Socket, Female (Not Shown - See Section 7 for Call-
Out) 1
0257858 MOTOR/GENERATOR ASSEMBLY Ref. E
101 7018126 Motor, Yanmar 1
102 Use 7023485 Alternator (was p/n 7020203) 1
103 Not Available Filter, Oil with Element 1
7020215 Element, Oil 1
104 7020167 Solenoid, Throttle 1
105 7020166 Swivel, In-line 1
106 to 109 Not Used
110 7018125 Handle, Regulator 1
111 Use 70000323 Relay, Bosch (was p/n 7020207) 2
112 3571412 Plate, Mounting, Oil Filter 1
113 7018127 Switch, Pressure 1
114 7020164 Fitting, Adapter 1
115 7020163 Adapter, Oil Drain 1
116 7020162 Bolt, Banjo 1
117 Not Serviced Washer, Rubber 1
118 7020204 Drain Line Assembly 1
119 7020161 Bracket 1
120 to 128 Not Used
129 3570581 Baseplate 1
FIGURE 1-10. MOTOR/GENERATOR INSTALLATION (M45 & M40 ONLY) (CONTINUED)
FIG & ITEM # PART NUMBER DESCRIPTION QTY. REV.