JLG 1500SJ Parts Manual User Manual
Page 136
2-102
SECTION 2 TURNTABLE
31
3960422
2
Gasket, AC Receptacle (60Hz Spec Only)
32
4060802
1
Guard, Switch
33
4240018
AR
Strap, Tie (Not Shown)
34
4300157
2
Stud
35
4360336
1
Switch, Toggle
36
4460051
1
Connector, Strain Relief (60Hz Spec Only)
37
4460071
1
Connector, Strain Relief (60Hz Spec Only)
38
4460315
2
Terminal, Spade (Not Shown - Use 1 each with items 30 & 31)
(60Hz Spec Only)
39
4460346
1
Terminal, Receptacle (60Hz Spec Only)
40
4460958
1
Receptacle (60Hz Spec Only)
41
Not Used
42
4711400
6
Flatwasher 1/4 Thin
43
4711600
1
Flatwasher 3/8 Thin
44
4751500
7
Flatwasher 5/16 Regular
45
4791400
2
Starwasher 1/4
46 to 47
Not Used
48
4891800
4
Flatwasher 1/2 Hardened
49
4922972
1
Harness, Generator Cable
B
4460225
1
Plug, Male 6 Position (Plugs into Generator)
4460226
6
Socket, Female (Use with 4460225)
4460807
1
Seal, Plug (Use with 4460225)
4460808
1
Seal, Interface (Use with 4460225)
77363233
1
Connector, Female 6 Position (Plugs into Control Box)
4460942
6
Socket, Female
50 to 51
Not Used
52
1001118599
1
Shield, Pulley
53
1001119250
1
Generator, 7500W
Use
70003631
1
Brushholder Assembly (Not Shown) (was p/n 7024484)
70001966
1
Bearing, Ball Radial (Located in Belt Tensioner Endbell - Not
Shown)
7027799
1
Block, Connector 6 Position (Not Shown)
70002460
1
Nut, Brass (Attaches p/n 7027799 to Cover) (Not Shown)
7024485
1
Breaker, Circuit 30Amp (Not Shown)
70001696
1
Boot, Breaker (Not Shown)
70002297
AR
Stud 1/4-20NC x 12-7/8 (Not Shown)
7026188
1
Clamp, Cable (Not Shown)
7026597
1
Connector with Leads (Not Shown)
70001100
1
Rotor/Armature (Not Shown)
70001384
1
Bearing, Ball Radial (Not Shown)
70003451
1
Stator (Not Shown)
Use
70004170
1
Plate, End Panel (Not Shown) (was p/n 70001972)
70000863
1
Fan (Not Shown)
70001974
1
Decal - Terminal Connections (Not Shown)
53A
Use
70004171
1
Key (was p/n 7024561)
53B
Use
70004170
1
Endbell, Rear (Brush Block End) (was p/n 70001385)
Use
70004170
1
Shroud, Endbell (was p/n 70002290)
70003452
1
Shroud, Endbell Panel
53C
70003450
1
Endbell, Front (Tensioner End)
53D
70001973
1
Decal - Warning Moving Parts
FIGURE 2-22. 7500W SKYPOWER GENERATOR INSTALLATION - CATERPILLAR MACHINES
ITEM #
PART NUMBER
QTY.
DESCRIPTION
REV.