JLG 4394RT Parts Manual User Manual
Page 54
2-18
SECTION 2 GROUND CONTROLS
507
7020023
1
Filter, Spin-On Fuel
70003463
1
Filter, Spin-On Fuel (RME Resistant - Bio-Diesel)
70001423
1
Bracket, Spin-On Fuel Filter
7027245
1
Filter, In-Line Fuel (Not Shown)
508
Not Used
509
7020414
1
V-Belt
510
7027903
3
Air Intake
Use 70001871
3
Gasket (Air Intake to Head) (was p/n 7020449)
70003469
1
Flange (Located on End of Air Intake)
70003468
1
O-Ring (Located on End of Air Intake)
3960407
1
Gasket (Located on Breather Side of Air Intake)
511
7020471
3
Gasket (Exhaust Manifold to Head)
512
7020486
1
Gasket (Exhaust Manifold to Exhaust Pipe)
513
AR
Starter Options:
Tier III Engine, Deutz Diesel
7020479
1
Starter
7026608
1
Relay/Solenoid, Starter
Tier IVi-Flex Engine, Deutz Diesel
70004057
1
Starter
70004058
1
Relay/Solenoid, Starter
514
AR
Generator Options:
Tier III Engine, Deutz Diesel
Use 7000663
1
Generator (was p/n 7020493)
7020494
1
Regulator, Voltage
Tier IVi-Flex Engine, Deutz Diesel
70004056
1
Generator
70001868
1
Regulator, Voltage
70001866
1
Gasket
515
7024565
1
Sensor, Speed Pick-up
516
7027790
1
Sensor, Oil Pressure
517
7027791
1
Sender, Engine Temperature (Not Shown - Located on RH Side
of Engine Near #1 Fuel Injector)
7027236
1
Sender, Engine Temperature (Not Shown - Located on RH Side
of Engine Near Oil Filter)
518
7027792
1
Actuator, Throttle
7027276
1
Spring
7027239
1
Solenoid, Throttle Start
519
Use 70003475
1
Thermostat (Not Shown - Located on RH Side of Engine) (was
p/n 7020459)
7020460
1
Spring, Thermostat (Not Shown - Located on RH Side of
Engine)
520
70001870
1
Flywheel
7024579
1
Rim, Gear
521
7027795
1
Deutz EMR2 Controller, Module
522
70000345
3
Glow Plug
523
70000783
1
Fan
524
1
Gasket, Head Options (Not Shown):
70003479
Gasket - 1 Notch
70003480
Gasket - 2 Notch
70003481
Gasket - 3 Notch
FIGURE 2-5. ENGINE INSTALLATION (DEUTZ D2011 ENGINE) (CONTINUED)
ITEM #
PART NUMBER
QTY.
DESCRIPTION
REV.