JLG 740AJ Parts Manual - Manual (Page 85)

3121161 740AJ 2-51
SECTION 2 TURNTABLE
321 7022162 2 Clamp
322 7022178 1 Sensor, Crank
323 7022149 1 Gasket Kit, Lower Manifold (Not Shown)
7025124 1 Gasket Kit, Upper Manifold (was p/n 7022148) (Not Shown)
7022144 1 Gasket, Upper Manifold Throttle (Not Shown)
324 7023657 1 Harness, TPS Harness (Not Shown)
325 3 Relay Options:
7023613 Prior to SN 0300073348 (2000174 Engines)
7023695 SN 0300073348 to SN 0300077500 (2000193 Engines)
326 7022153 1 Pump, Water
7022154 1 Gasket, Water Pump
7022155 1 Sensor, Water Temperature (Not Shown)
7027411 1 Sender, Water (Not Shown)
7022156 1 Thermostat (Not Shown)
7023644 1 Hose, Water Pump (By-Pass) (Not Shown)
327 2720341 1 Horn, Rubber Air
328 1600363 1 Module, EPM (SN 0300073348 to SN 0300077500) (was p/n
7023684)
1 EPM Update Kit Options:
Note: Contact JLG Service Dept to determine which kit is
required.
2915195 EPM Update Kit (was p/n 7023685)
2915196 EPM Update Kit (was p/n 7023686)
329 70002567 1 Tensioner, Belt
330 7019925 1 PCV Valve (Not Shown)
331 7019930 1 Coil, Ignition (Not Shown)
7022157 1 Wire Set, Spark Plug (Not Shown)
7019932 4 Spark Plug (Not Shown)
332 7022151 1 Cap, Oil Fill
333 7022150 1 Belt, Timing
334 7027402 1 Belt, Drive (was p/n 7019979)
— — — — — — — — — —
3124114 1 Service Manual, Ford EFI System Diagnostic
Ref MUFFLER INSTALLATIONS
0258390 Ref Standard Spark Arresting 1
0258391 Ref Optional Catalytic 1
401 1 Muffler Options:
3220113 Standard Spark Arresting
3220114 Optional Catalytic
70001017 1 Clamp
402 0340046 2 Band
403 0902309 1 Bracket, Muffler
404 0641507 4 Bolt 5/16in-18NC x 7/8in
405 4711500 8 Flatwasher 5/16in Narrow
406 3311505 4 Locknut 5/16in-18NC
407 4567073 1 Tube, Exhaust
70001017 1 Clamp
FIGURE 2-10. FORD ENGINE INSTALLATION (PRIOR TO SN 0300077500) (CONTINUED)
ITEM # PART NUMBER QTY. DESCRIPTION REV.