JLG 800A_AJ Parts Manual - Manual (Page 81)

3120859 2-55
SECTION 2 TURNTABLE
S
E
C
T
I
O
N
2
T
U
R
N
T
A
B
L
E
.
FIGURE 2-16. GROUND CONTROL BOX ASSEMBLY (ADE SYSTEM) (SN 0300064432 TO SN
0300069000)
FIG & ITEM # PART NUMBER DESCRIPTION QTY. REV.
GROUND CONTROL BOX ASSEMBLIES Ref
0861504 800A with Deutz Engine Ref H
0861505 800AJ with Deutz Engine Ref G
1 0100011 Compound, Locking AR
2 0630518 Capscrew, Button Head 2
3 0630548 Tap, Bolt 2-1/2in 5
4 0641506 Bolt 5/16in-18NC x 3/4in 4
5 0861407 Box, Fiberglass 1
5A 7020246 Latch 2
6 Use 2915014 Module, Ground Control (was p/n 1600327) 1
7 1670829 Bezel 1
8 1704833 Decal - Ground Control Display 1
9 Decal - Faceplate Options: 1
1703467 800A
1703468 800AJ
10 2420172 Gauge, Hourmeter 1
11 2760105 Housing, Display Light 1
12 3300205 Nut, Retainer 4
13 3300408 Locknut, Plastic Insert AR
14 3311401 Nut 1/4in-20NC 10
15 3539219 Plate, Reinforcement 1
16 3740049 Relay 2
17 3900268 Screw, Flange #10 x 1/2in 2
18 3910804 Screw #8-32NC x 1/4in 6
19 4060906 Shield, Toggle Switch 8
20 4070987 Shim (.015) 1
21 4360328 Switch, Toggle 8
22 4360470 Switch, Key 1
22A 2860030 Key Replacement 1
23 4360475 Switch, Emergency Stop 1
7020175 Cap, Mushroom 1
7020176 Block, Contact 1
24 4360476 Switch, Contact Block 1
25 4460426 Connector, Strain Relief 2
26 4460470 Nut, Terminal 1
27 4460471 Lockwasher, Terminal 1
28 4460488 Mounting Base, Terminal 7
29 4460526 Connector, Strain Relief 1
30 4460874 Connector, Natural 1
31 4460875 Connector, Gray 1
32 4740444 Washer, Special 8
33 4751400 Flatwasher 1/4in 20
34 4761400 Lockwasher 1/4in 10
35 4922666 Harness, Analyzer Cable (Not Shown) 1
36 4460905 Connector, Amp Seal 4
37 0100048 Grease, Dielectric AR
38 to 41 Not Used