JLG 15SP Operator Manual - Manual (Page 9)

TABLE OF CONTENTS
3120774 – JLG Lift – iii
SECTION - PARAGRAPH, SUBJECT PAGE SECTION - PARAGRAPH, SUBJECT PAGE
SECTION - 7 - GENERAL SPECIFICATIONS AND OPERATOR
MAINTENANCE
7.1 INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1
7.2 GENERAL SPECIFICATIONS . . . . . . . . . . . . . . . . . . . 7-2
Machine Specifications . . . . . . . . . . . . . . . . . . . . 7-2
Electrical Specifications . . . . . . . . . . . . . . . . . . . . 7-3
Machine Component Weights . . . . . . . . . . . . . . . 7-5
Serial Number Locations . . . . . . . . . . . . . . . . . . . . . 7-5
7.3 OPERATOR MAINTENANCE . . . . . . . . . . . . . . . . . . . . 7-6
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-6
Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-7
Lubrication Points . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-8
7.4 SUPPLEMENTAL INFORMATION . . . . . . . . . . . . . . . 7-10
SECTION - 8 - INSPECTION AND REPAIR LOG
LIST OF FIGURES
1-1. Read Your Manual. . . . . . . . . . . . . . . . . . . . . . . . . 1-2
1-2. Always Look in the Direction of Movement.
Watch for Overhead and Other Obstructions. . . . 1-4
1-3. Death or Serious Injury Could Occur from
a Tip Over . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4
1-4. All Personnel Must Stand Clear When
Platform Is Being Raised Or Lowered. . . . . . . . . . 1-5
1-5. Falling from Platform could cause
Death or Serious Injury . . . . . . . . . . . . . . . . . . . . . 1-6
1-6. Use Handles Provided On Mast Crossbar To
Move Machine . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-9
1-7. Do Not Move Unit on Soft or Uneven Surfaces or
Over Obstructions, Bumps, Debris, Etc.. . . . . . . . 1-9
1-8. Two People May Be Required on Slopes Up To
Five Degrees. Also Always Travel With Platform
End On The Low Side of Slope. . . . . . . . . . . . . . 1-10
2-1. Daily Walk-Around Inspection. . . . . . . . . . . . . . . . 2-6
3-1. Ground Control Station . . . . . . . . . . . . . . . . . . . . . 3-2
3-2. Manual Descent Valve Location . . . . . . . . . . . . . . 3-3
3-3. Platform Control Station . . . . . . . . . . . . . . . . . . . . 3-4
3-4. SP Machine - Decal Installation . . . . . . . . . . . . . . 3-5
4-1. Battery Box and Charger Assembly -
(Original Design) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3