Echo 77412 Owners Manual v.5 - Manual (Page 7)

4.5 INCH CHIPPER 5
SAFETY
Shut off machine immediately if the machine becomes
clogged, the cutting mechanism strikes any foreign
object, or the machine starts vibrating or making an
unusual noise. Shut off power source, disconnect
spark plug wire from spark plug and make sure all
moving parts have come to a complete stop. After
machine stops:
Inspect for damage.
Replace or repair any damaged
parts.
Check for and tighten any loose
parts.
Check blade bolts for proper torque after every 8 hours
of operation. Check blades and rotate or resharpen
daily or as required to keep blades sharp. Failure to do
so may cause poor performance, damage or personal
injury and will void the machine warranty.
12.
A.
B.
C.
13.
1.4 oPeraTion SafeTY (conT.)
1.5 PTo SafeTY
Read and follow instructions on pTO safety decals.
Stay alert and pay attention when pTO is operating.
keep bystanders, especially children, away from pTO
driveline.
Check the driveline to ensure it is attached securely
to the power supply.
keep guards and shields in place at all times while
operating. Disengage pTO, shut off power source,
remove key and make sure all moving parts have
come to a complete stop before removing guards or
shields.
Clothing worn by op-
erator must be fairly
tight. Never wear loose
fitted jackets, shirts, or
pants when working
around the pTO. Tie
long hair back or put
under a cap.
keep hydraulic hoses,
electric cords, chains and other items from contacting
the driveline.
Do not exceed the recommended 540 Rpm pTO
operating speed.
1.
2.
3.
4.
5.
6.
7.
8.
Before inspecting or ser-
vicing the pTO drive area,
disengage the driveline,
shut off power source,
remove key and make
sure all moving parts
have come to a complete
stop.
keep hands, feet, and
clothing away from all
pTO drive parts.
Do not clean, lubricate or adjust the PTO shaft when
it is running.
9.
10.
11.
1.6 baTTerY SafeTY
Improper use and care of the battery on electric start mod-
els can result in serious personal injury or property dam-
age. Always observe the following safety precautions.
poison/Danger - Causes Severe Burns. The battery
contains sulfuric acid. Avoid contact with skin, eyes
or clothing. keep out of reach of children.
ANTIDOTE-External Contact: Flush immediately
with lots of water.
ANTIDOTE-Internal: Drink large quantities of water
or milk. Follow with milk of magnesia, beaten egg
or vegetable oil. Call a physician immediately.
ANTIDOTE-Eye Contact: Flush with water for 15
minutes. Get prompt medical attention.
The battery produces explosive gases. keep sparks,
flame or cigarettes away. ventilate area when charg-
ing battery. Always wear safety goggles when working
near battery.
The battery contains toxic materials. Do not damage
battery case. If case is broken or damaged, avoid
contact with battery contents.
Neutralize acid spills with a baking soda and water
solution.
properly dispose of a damaged or worn-out battery.
Check with local authorities for proper disposal meth-
ods.
Do not short circuit battery. Severe fumes and fire
can result.
Before working with electrical wires or components,
disconnect battery ground (negative) cable first. Dis-
connect positive cable second. Reverse this order
when reconnecting battery cables.
1.
2.
3.
4.
5.
6.
7.
danger / PoiSon
SHIELD EyES
ExpLOSIvE GASES
CAN CAuSE
BLINDNESS OR
INjuRy
NO
• SpARkS
• FLAmES
• SmOkING
SuLFuRIC
ACID
CAN CAuSE
BLINDNESS OR
SEvERE BuRNS
FLuSH EyES
ImmEDIATELy
WITH WATER
GET
mEDICAL
HELp
FAST
kEEp OuT OF THE REACH OF CHILDREN. DO NOT TIp. kEEp vENT CApS TIGHT AND LEvEL.