Checkline LS-REGSENSOR - Manual (Page 2)

Sensor Selection Guide
Model Description
Product subject to change without notice .
DIMENSIONS
SUPPL Y VOLTAGE
• 10 to 30 VDC
•
P olarity Protected
CURRENT REQ UIREMENTS
• 45 milliamps (e xclusive of load)
OUTPUT TRANSISTORS
• (1) NPN and (1) PNP output tr ansistors
• Sensor outputs can sink or source up to 150 milliamps
(current limit)
• All outputs are contin uously short-circuit protected
REMO TE AUTOSET™ INPUT
• Opto isolated momentar y sinking input (10 milliamps)
RESPONSE TIME
• Light state response = 100 microseconds
• Dar k state response = 100 microseconds
LED LIGHT SOURCE
• Pulse modulated high intensity white LED
PUSHB UTTON CONTROL
• One pushb utton set-up
• A utomatic set-up routines based on web opacity
• Sim ultaneously pushing both buttons inverts the output
• On po wer-up, simultaneously pushing both buttons enables
the program mode, allowing the pulse stretcher to be
enabled or disabled
SPECIFICATIONS
HYSTERESIS
• Minimal h ysteresis promotes detection of low contrast
registration marks
LIGHT IMMUNITY
•
Responds to sensor’ s pulse modulated light source …
immune to most ambient light
INDICA TORS
• Green A UTOSET™ LED flashes when AUTOSET™ routine is
activated and stays illuminated when AUTOSET™ is completed
• Red Output LED illuminates when sensor’ s output
transistors are “ON”
• On po wer-up, the AUTOSET™ LED flashes twice when
the pulse stretcher is enabled
AMBIENT TEMPERATURE
• - 40°C to 70°C (- 40°F to 158°F)
R UGGED CONSTRUCTION
• Chemical resistance to harsh cleaners , such as
detergents, alcohols, and ketones
• W aterproof ratings: NEMA 4 and IP66
• Conf orms to heavy industry grade CE and UL requirements
SELECT ABLE PULSE STRETCHER
• Pro vides a minimum of 10 milliseconds output duration
MEWL White LED, 5-conductor cable
MEWLC White LED, 5-pin micro
connector on a 6” pigtail
Cab le Selection Guide (5 Wire)
Model Micro Cable (M12) Description
GSEC-2MU 6.5 ft. (2.0m) Low Cost, Unshielded
GSEC-5MU 16 ft. (5.0m) Low Cost, Unshielded
GSEC-6 6 ft. (1.8m) Shielded Cable
GSEC-15 15 ft. (4.6m) Shielded Cable
GPSEC-15 15 ft. (4.6m) Shielded Cable
C H E C K • L I N E ® – P
R E C I S I O N
Q
U A L I T Y
C
O N T R O L
I
N S T R U M E N T S
Electromatic Equipment Co., Inc.
600 Oakland Ave.
Cedarhurst, N Y 11516 —USA Tel: (800) 645-4330 (USA & Canada)
Tel: (516) 295-4300
Fax: (516) 295-4399 Email: [email protected]
Website: www.checkline.com