Step 2”move dishwasher, Warning, Step 3” remove toekick – GE 165D4051G009 User Manual
Page 2: Step 4”remove old springs, Step 5“lnstall new springs, Step 7-reinstall toekick
Attention! The text in this document has been recognized automatically. To view the original document, you can use the "Original mode".
step l“Turn off power and water Step 6-Check door balance
•Turn off power supply.
•Turn off water supply.
• Lotch dishwasher door.
Step 2”Move dishwasher
• Remove the two screws securing the dishwasher to the
countertop or side.
• Pull the unit out from the cabinets approximately 10", until
the door springs are exposed.
A
WARNING:
■ All dishwashers can tip when removed from enclosure.
>
Injury to persons could result.
>
Use caution when opening door.
Step 3”
Remove
toekick
' Remove the screws on
each side of the toekick
face.
• Retain screws.
• Remove the toekick from
the dishwasher and set
aside.
• Check the door balance by opening and closing the door
« If door drops open when released, increase spring tension.
If door closes when released, decrease tension.
Note:
Increase or decrease tension as shown. Adjust both springs to
the same tension setting to correct balance.
Tip: If door does
not open easily or
falls too quickly,
check spring coble
routing. The cable
is held in place by
"shoulders" on the
pulley. Check to be
sure cable has not
¡Correct
slipped over the
pulley shoulders
and onto the axle.
incorrect
Step 4”Remove old springs
• Grasp the upper end of the spring attached to the dishwasher
frame and release the hook.
• Release opposite end of the spring from the tension cable
and remove the spring.
Step 5“lnstall
new springs
• Place the short end of
the spring hook into the
eyelet of the tension
cable.
• Stretch the long end of
spring and hook into the
lowest notch of the frame
bracket.
• Repeat the same
procedure for the
opposite side.
Insert \
Hook \
Over i
Bracket /
Step 7-Reinstall toekick
• slide dishwasher back into opening.
DO NOT PUSH AGAINST
FRONT PANEL WITH KNEES. DAMAGE WILL OCCUR.
• Reinstall the 2 screws securing the dishwasher to the
countertop or sides and ensure door springs do not contoct
water line, fill hose, wiring, etc.
• Turn water on.
• Turn electrical power on.
Correct
Incorrect
GE Consumer & Industrial
General Electric Company
Louisville, Kentucky 40225
ge.com
Knee. Damage to The
Door Panel Will Occur.
SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE
Pub. No. 31W0593
DWG. N0.206C1559P137
05DW297 5/05