PS Engineering PM1200 Installation Manual - Manual (Page 7)

200-196-0104 Page 7 March 2013 Rev. 12
PM1200, With EXPANSION Wiring P/N 11960-EXP Only
1A
11-33 VDC
14
1
11960 Sub-D DB-25 Female on unit, Male on harness
To Aircraft Radio
Phone Hi
17
4
Power In
Ground
A/C Radio Phone Audio Hi
A/C Radio Phone Audio Lo
18
5 Pilot Phone Audio Hi
Pilot Phone Audio Lo
Copilot Phones
Copilot Phones Hi
Copilot Phones Lo 19
6
20
7
Music Jack
22
21
Music Input Hi
Music Input Lo
Copilot Mic PTT
Copilot Mic Audio Hi
Mic Audio Lo
Copilot PTT
Pilot Mic PTT
Pilot Mic Audio Hi
Pilot Mic Audio Lo
Pilot PTT
12
25
24
23
11
To Aircraft Radio
Phone Low
AUX Headphone Jack
Pilot Phones
NOTES:
1. All wire must conform to MIL-22759
or 27500. Minumum 24 gage shielded wire.
2. Use 2- and 3-conductor with shield as indicated.
3. Use insulating washers on all jacks.
4. Connect shields at intercom end only
5. AUX headphone and microphone jacks are required.
6. UNIT MUST BE COMPATABLE WITH EXPANSION, P/N 11960-EXP
7. Music connected to the PM1200 will appear in
Expansion when in "ALL" mode. Music connected to expansion
will be present in passenger headset only in "Crew" mode.
One music source can be connected to BOTH, if left and right channel isolation is considered.
8. Radio and ICS PTT switches NOT supplied.
Pilot Mic Jack
Aircraft Radio PTT
Aircraft Mic Audio Hi
Aircraft Mic Audio Lo
REV
DATE: SHEET OF
TITLE:
DOCUMENT NUMBER: SIZE
PM1200 Expansion (11960E) WIRING
120-196-0100 4
1/24/11 1 1
9800 MARTEL ROAD, LENOIR CITY TN 37772
16 Pilot ICS PTT
Copilot ICS PTT
Pilot ICS PTT
15
PTT Common 2
Copilot ICS PTT
10
IntelliPAX
Expansion Unit
P/N 11616 or
11616R (remote)
Expansion Power
Expansion Out
Expansion In
Expansion Ground
8
13
3
1
2
3
14
15
Aux Mic Jack
Aircraft Radio PTT
To Aircraft Radio Mic Audio Lo
To Aircraft Radio Mic Audio Hi
Note 7
Note 8
Note 8
Note 8
Note 8