Winco W15PTOS/D - Manual (Page 3)

Page 1
60706-179-8100
SAFETY INFORMATION
This generator set has been designed and manufac-
tured to allow safe, reliable performance. Poor mainte-
nance, improper or careless use can result in potential
deadly hazards; from electrical shock, exhaust gas
asphyxiation, or fire. Please read all safety instructions
carefully before installation or use. Keep these instruc-
tions handy for future reference. Take special note
and follow all warnings on the unit labels and in the
manuals.
ANSI SAFETY DEFINITIONS
DANGER:
DANGER indicates an imminently hazardous situation
which, if not avoided, will result in death or serious
injury. This signal word is to be limited to the most
extreme situations.
WARNING:
WARNING indicates a potentially hazardous situation
which, if not avoided, could result in death or serious
injury.
CAUTION:
CAUTION indicates a potentially hazardous situation
which, if not avoided, may result in minor or moderate
injury. It may also be used to alert against unsafe
practices.
NOTE:
CAUTION is also used on the unit labels and in this
manual to indicate a situation that could result in
serious damage or destruction of the equipment and
possible personal injury.
INTRODUCTION
The words generator and alternator are used inter-
changeably but have the same meaning.
This manual covers standby generators driven by the
power take-off of a compact tractor. This generator
use a external voltage regulator excitation system. All
generators are carefully inspected, tested and pack-
aged for shipment at the factory. The generator should
be unpacked as early as possible upon receipt and
inspected for damage which may have occurred during
shipment. Any damage noted should be promptly
reported to the carrier in order that a claim can be filed
to recover the cost of the damage. If at all possible,
this damage should be noted on the freight bill at the
time of delivery. If the damage appears to be of a
major nature, the generator should not be operated
until the fault has been corrected.
Tractor driven generators are designed to deliver
voltage and current similar to that of the normal power
line. Equipment that can be operated on normal power
can also be operated by the generator, provided that
the capacity of the generator is not exceeded. It
should be remembered that the power line, for all
practical purposes, is backed by an unlimited genera-
tor.
When not in use the generator should be stored in a
clean dry location. All types of mechanical equipment
suffer from long periods of storage without use. The
generator should be used at frequent intervals to
prevent deterioration and detect possible fault before
an emergency condition develops.
All PTO units have a full control panel with features like large frequency meter, mainline circuit breaker, convenience
and full load 4-wire receptacles. The full load matching plug is also included for customers load connection cord set.
Traditional Winco power, convenience and reliability are standard features of this new series of compact PTO genera-
tors
.
FEATURES BY MODEL
TRACTOR INPUT GEAR MOTOR ** WATTS AMPS @
PTO HP SHAFT LUBE STARTING MAX / RATED 120/240V FEATURES*
W15PTOS/C 36/30 1-3/8 6SPL 16 OZ 8 HP 18,000 / 15,000 83 / 60 1, 2, 3, 4, 5, 6
**MOTOR STARTING – CODE ‘G’ CAPACITOR START –
*FEATURES – LISTED BELOW BY REFERENCE NUMBER WITH EXPLANATION –
1 – Brushless, low harmonic design with skewed rotor and damper windings for minimal load noise
2 – Capacitor Excitation
3 – Dual voltage - 120/240 volt output
4 – 4 wire Load connection plug for convenient full load 120/240 volt output cordset
5 – 15Amp duplex convenience receptacle
6 – Large face Frequency meter for setting proper speed