Star Headlight & Lantern 1166HM Teardrop - Manual

PLITSTR126 REV. K 3/24/09
If you have any questions concerning this or any other product,
please contact our Customer Service Department at (585) 226-9787.
If a product must be returned for any reason, please contact our Customer Service
Department to obtain a Returned Goods Authorization Number (RGA #) before you ship the
product back. Please write the RGA # clearly on the package near the mailing label.
MOUNTING INSTRUCTIONS
FOR MAGNET MOUNT LIGHTS
1. IMPORTANT: Please read all of the following instructions before installing your new Star
warning light.
2. CAUTION: Please be sure to check that your cigarette plug outlet is properly fused.
Testing the light before this fuse is properly installed will void the warranty on
the light.
3. Some of our warning lights come with a dome hood included for driver eye protection
during dash mounted operation. Hoods may be ordered for most of the other models in
which a hood is not included.
4. A metal plate is provided with certain small models to facilitate mounting the new warning
light onto your dashboard. Peel the back off of the unattached piece of Velcro and affix it
to the dashboard. Then, mate it with the other half of the Velcro attached to the metal
plate at the factory. This will provide you with a metal surface to which your new
warning light can be mounted using the attached magnet and easily removed from. It is
the sole responsibility of the owner to ensure the warning light and metal pl ate
are secure.
5. For all magnet mount models, if you are mounting the light on the roof of your
vehicle, take extreme care to ensure that the magnet is firmly seated on your roof, and
that the pull of the magnet is sufficient to secure the light in place. As the composition of
the metal in the roofs of different vehicles may vary, as well as the contour, texture
and/or condition, Star cannot guarantee the ability of the light to remain in place upon a
moving vehicle. It is the sole responsibility of the owner to ensure the warning
light is secure.
6. Once the light is secured, route your cord such that it does not interfere with the vision of
the driver or the operation of any controls, including, but not limited to, the steering wheel,
gear shifter, and/or airbag.
7. This light has been factory tested and approved. If the light fails to work when the plug is
inserted into the cigarette plug socket, twist the plug a few times to remove any ash or
other deposits which might be preventing a good contact from being made. If the problem
persists, check for a fuse inside of the plug itself. If present, remove the fuse from the
circuit, check to see if it has blown, and clean the lighter socket and contact surfaces.
Reconnect the fuse and test the light again.
If you are mounting the light on the roof of your vehicle, take extreme care to ensure
that the magnet is firmly seated on your roof, and that the pull of the magnet is
sufficient to secure the light in place. As the composition of the metal in the roofs of
different vehicles may vary, as well as the contour, texture and/or condition, Star
cannot guarantee the ability of the light to remain in place upon a moving vehicle. It
is the sole responsibility of the owner to ensure the warning light is secure. ONE YEAR LIMITED WARRANTY
The manufacturer warrants each new product, under normal use, against factory
defects in material and workmanship for one year after the date of purchase. The
owner will be r esponsible for returning to the Service Center any defective
item(s) with the transportation costs prepaid. The manufacturer will, without
charge, repair or replace at its option, products, or part(s), which its inspection
determines to be defective. Repaired or replacement item(s) will be returned to
the purchaser with transportation costs prepaid from the service point. A copy of
the purchaser's receipt must be returned with the defective item(s) in order to
qualify for the warranty coverage.
Exclus ions from this warranty include, but are not limited to, bulbs, strobe tubes,
domes, and/or the finish. This warranty shall not apply to any light, which has been
altered, such that in the manufacturer's judgment, the performance or reliability
has been affected, or if any damage has resulted from abnormal use or service.
This warranty does not apply to defect or damage occurring as a result of
disaster, accident, abuse, misuse, lightning, power surges, or failure to follow
instructions in any enclosed manuals. Any damage or defects occurring as a result
of any unauthorized service or repairs by unauthorized persons shall be excluded
from this warranty.
There are no warranties expressed or implied (including any warranty of
merchantability or fitness), w hich extend this warranty period. The loss of use of
the product, loss of time, inconvenience, commercial loss or consequential
damages, including costs of any labor, are not covered. The manufacturer
reserves the right to change the design of the produc t without assuming any
obligation to modify any product previously manufactured.
This warranty gives you specific legal rights. You might also have additional rights,
which may vary from state to state. Some states do not allow limitations on how
long an implied warranty lasts. Some states do not allow the exclusion or
limitation of incidental or consequential damages. Therefore, the above
limitation(s) or exclusion(s) may not apply to you.