Caution, Important, F. placing air conditioner on the roof – Dometic 630515.336 User Manual

Page 9

Advertising
background image

620515, 620525, 620526, 630515 & 630516 Installation Instructions

9

Important:

RJ-11-6C4P connectors must be installed

as shown in FIG. 8A, 8B & 8C.

3. Comfort Control Center

TM

Installation

a.

Carefully remove the base plate from the Com-
fort Control Center

TM

. This may be accom-

plished by inserting a small screwdriver under
the tab on the bottom edge of the front cover
and gently prying. See FIG. 9.

b.

Insert the control cable through the hole in the
base plate and mount the plate to the wall with
two (2) screws provided. Check the alignment to
ensure level installation.

c.

Install the control cable RJ-11-6C4P connector
into the back of the Comfort Control Center
and snap onto the base plate. See FIG. 9.

F. Placing Air Conditioner On The Roof

1. Remove the air conditioner from the carton and dis-

card carton. See FIG. 10.

2. Place the air conditioner on the roof.

This unit weighs approximately 100 pounds.
To prevent back injury, use a mechanical hoist
to place Air Conditioner on roof.

Do not slide the unit. This may damage the
roof gasket attached to the bottom and may
create a leaky installation.

CAUTION

FIG. 8A

FIG. 8B

Flat Four Conductor Cable

RJ-11-6C4P
Connector

Pin 1

FIG. 8C

Black

Green

Red

Yellow

Black

Green

Red

Yellow

Insert Screwdriver

under Tab

Insert Screwdriver

under Tab

MO

DE

MODE

FAN

FAN

UP

UP

DO

WN

DOWN

OFF

ON

OFF

ON

ZO

NE

ZONE

TEM

P

TEMP

FIG. 9

FIG. 11

FRONT

FIG. 10

3. Lift and place the unit over the prepared opening using

the gasket on the unit as a guide. See FIG. 11.

4. Place the Return Air Kit inside the RV. This box

contains mounting hardware for the air conditioner
and will be used inside the RV.

This completes the outside work. Minor adjustments

can be done from the inside of the RV if required.

Advertising
This manual is related to the following products: