Montigo M38ODV ST - Manual (Page 2)

XG0128 Page 2
M38ODV-ST Direct Vented Fireplace
Introduction
The M38ODV-ST model with a continuous pilot, is a direct-vented
See-Thru Gas Fireplace with glass doors on two sides and an
adjustable burner
This manual covers the M38ODV-ST model unless otherwise speci-
fied. Sections which are specific to a particular model are marked with
a
symbol, plus the appropriate model number.
The M38ODV-ST is rated for:
„ Natural Gas at 32,000 BTU/H (9.38 Kilowatts) Input
„ Propane at 32,000 BTU/H (9.38 Kilowatts) Input
The Montigo warranty will be voided by, and Montigo disclaims any
responsibility for, the following actions:
„ Modification of the fireplace and/or components including Direct-
Vent assembly or glass doors.
„ Use of any component part not manufactured or approved by
Montigo in combination with this Montigo fireplace system.
„ Installation other than as instructed in this manual.
Consult your local Gas Inspection Branch on installation requirements
for factory-built gas fireplaces. Installation & repairs should be done by
a qualified contractor.
Installations in Canada must conform to the current CAN/CGA B-
149.1 and .2 Gas Installation Code and local regulations. When the
unit employs the
optional Fan Kit, it must be electrically grounded in
accordance with CSA C22.1 Canadian Electrical Code Part 1 and/or
Local Codes.
Installations in the USA must conform to the National Fuel Gas
Code, ANSI Z223.1-1988. When the unit employs the
optional Fan Kit
it must be grounded in accordance with local codes or, in the absence
of local codes, with the National Electrical Code, ANSI/NFPA 70-1987.
A manufactured (mobile) home OEM installation in the United
States must conform with the Manufactured Home Construction and
Safety Standard,
Title 24 CFR, Part 3280, or, when such a standard is
not applicable, the Standard for Manufactured Home Installations,
ANSI / NCSBCS A225.1. In Canada, the installation must conform to
the Standard for Gas Equipped Recreational Vehicles and Mobile
Housing, CSA Z240.4.
Table Of Contents
Introduction ............................................................................. 2
Installation ........................................................................ 3 - 11
Installing the Fireplace Shell ........................................... 3
Installing the Gasline ...................................................... 4
The Remote Switch ....................................................... 4
Direct Vent Installation ................................................... 4
General Requirements ...................................... 4
Terminations ..................................................... 5
Horizontal Venting Runs .................................... 6
Vertical Venting Runs ........................................ 8
Finishing around the fireplace
Facing ............................................................. 8
Mantels and Surrounds ..................................... 8
Installing the Logset ....................................................... 9
Removing and Installing the Door .................................. 9
Operation
Adjusting the Center Burner ........................................ 10
Lighting Instructions - Model M38ODV-ST ................... 11
Maintenance
Cleaning ...................................................................... 12
Pilot Burner Adjustment ............................................... 12
Gas Control Valve ........................................................ 12
Troubleshooting ........................................................... 12
Appendix A - Spare Parts & Accessories ............................ 13
Warranty ................................................................................. 14
CAUTIONS
Due to its high operating temperatures, the appliance
should be located out of traffic & away from furniture and
draperies.
• Children and adults should be alerted to the hazards
of the high surface temperature, which could cause
burns or clothing ignition.
• Young children should be carefully supervised when
they are in the same room as the appliance.
• Clothing or other flammable materials should not be
placed on or near the appliance.