Sealey ASCL2 - Manual

InstructIon manual for:
aluminium scaffold ladder
model no:
ascl2
thank you for purchasing a sealey product. manufactured to a high standard this product will, if used according to these instructions
and properly maintained, give you years of trouble free performance.
1. safeTY insTrucTions
IMPORTANT: Please read THese insTrucTions carefullY. noTe THe safe oPeraTional reQuiremenTs, WarninGs & cauTions.
use THe ProducT correcTlY and WiTH care for THe PurPose for WHicH iT is inTended. failure To do so maY cause
damaGe or Personal inJurY and Will inValidaTe THe WarranTY. Please KeeP insTrucTions safe for fuTure use.
2. inTroducTion & sPecificaTion
1.1 General safeTY
 DANGER! Take care when using and moving extended ladders in the vicinity of power cables - risk of potentially fatal electric shock.

WarninG! Ensure Health and safety, local authority, and general workshop practice regulations are adhered to when using this
equipment.

familiarise yourself with the application and limitations of the ladder, as well as the potential hazards.

maintain the equipment in good condition.

replace or repair damaged parts. use genuine parts only. unauthorised parts may be dangerous and will invalidate the warranty.
 Keep the work area clean, uncluttered and ensure there is adequate lighting.

WarninG! use ladder on level and solid ground and either have an assistant stand on the lowest rung or otherwise anchor the base of
the ladder to prevent slipping.

WarninG! do noT use the ladder, step ladder or scaffolding on sloping ground. When viewed from the front, the top of the ladder
section(s) must always be directly above the base.

Place ladder at an angle of 65° to 75° - foot of ladder 1 metre from wall for each 3 metres up - for stability.

Where possible, lash top of ladder to a fixture to prevent slipping.

WarninG! never over-reach when on the ladder, step ladder or scaffolding.

Keep children and unauthorised persons away from the working area.

do noT use the ladder, step ladder or scaffolding for any purpose other than that for which they are designed.

do noT use the equipment if any parts are damaged or missing as this may cause failure and/or personal injury.

do noT exceed the rated capacity of the ladder, step ladder or scaffolding.

do noT climb scaffolding to get onto platform. always access the platform using a separate set of steps.

do noT allow children to climb the ladder, step ladder or scaffolding.

do noT use the equipment when you are tired or under the influence of alcohol, drugs or intoxicating medication.
2.1 introduction
En131 approved four-way scaffold ladder. two six-rung alumimium ladders can be used as
extending ladder, single ladders, step ladder or complete scaffolding unit. supplied with hand
rail.
2.2 specification
maximum load . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .150kg
Extension ladder maximum Height . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2700mm
closed length . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1670mm
step ladder Height. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1600mm
Platform length . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1320mm
maximum Platform Height . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .950mm
maximum Width (across feet). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .785mm
Weight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14.7kg
fig.2 fig.3
3. assemBlY & use
3.1 Work Platform
 WarninG! assembling the work platform is a two-man task.
3.1.1 Bolt the foot cross members to the bottom of each ladder. the feet are already attached to the cross members. refer to fig.2.
3.1.2 attach the platform, at the desired height, to one ladder only.
note: ensure that the hole for the hand rail is nearest to the outer face of the ladder.
Original Language Version ascl2 Issue: 1 - 25/07/11
fig.1