Thermo Pride Spirit Gas TG8S Single Stage PSC 80% - Manual (Page 31)

998491-UIM-B-1013
Johnson Controls Unitary Products 31
SECTION XII: START UP SHEET
Water Heater BTUH Input Fan Assisted?
33" 80% AFUE Single Stage Gas Furnace Start Up Sheet
Proper furnace start up is critical to customer comfort and equipment longevity
Name Address
City State or Province Zip or Postal Code
Furnace Model Furnace Serial
Evaporator Coil Model Evaporator Coil Serial
Upflow Downflow Horizontal Left Horizontal Right
Unit is level
Venting system is the proper size, within the limitations of the chart in the
installation instructions, properly connected to the furnace, and properly pitched
Filter Type
Connector Size Connector Length
# 0f 45 Degree Ells # of 90 Degree Ells
Polarity is correct (black is L1 (hot), white is N (neutral) Ground wire is connected Line voltage to furnace (AC)
Low voltage value between "R" and "C" on furnace control board (volts AC)
Thermostat Type Other System Equipment and Accessories
Owner Information
Equipment Data
Furnace Configuration
Venting: B Vent
Electrical: Line Voltage
Outdoor Unit Model Outdoor Unit Serial
Filter, Thermostat, Accessories
Filter Location(s)
Connections -- All Per Installation Instructions and Local Code
Gas piping is connected (including drip leg) Supply plenum and return air are connected
Filter Size
Vent system is connected
Thermostat wiring is complete Thermostat heat anticipator set to .45 (if present)
Electrical: Low Voltage
Technician Performing Start-Up Installing Contractor Name
Start-Up Date
Continued on next Page
B Vent Connector Single Wall Connector
Connector Length
# 0f 45 Degree Ells # of 90 Degree Ells
Connector Size
Venting: Lined Masonry Chimney
Other appliances in same common vent:
Vent Pipe Size
Furnace BTUH Input Fan Assisted?
Other BTUH Input Fan Assisted?
Vertical Termination
Horizontal Term. (with External Power Vent)
Total Height
Chimney Height
# 0f 45 Degree Ells # of 90 Degree Ells Vent Pipe Size
Y N
N Y
Y N