Hearth and Home Technologies 3500P User Manual
Magnum countryside, Owner’s manual, Biomass corn/wood pellet stove /fireplace insert
Advertising
This manual is related to the following products:
Table of contents
Document Outline
- TABLE OF CONTENTS
- SHELLED CORN (11-12 percent moisture recommended)
- When you receive your MagnuM Countryside Corn/Pellet Stove, Leg unit or Fireplace Insert, be careful to inspect all parts and components to make sure that nothing was damaged or lost in shipment. If there was shipping damage, be sure to report it to your Countryside reseller, or the shipping company that delivered your unit. Freight damage claims must be made to the Freight Company immediately. If parts are missing contact your local MagnuM Countryside dealer or contact the factory right away. Your satisfaction is our top priority.
- MAGNUM COUNTRY SIDE REPLACEMENT PARTS LIST
- ORDER #
- DESCRIPTION
- MF3511
- Bronze Bushing (fuel stirrer shaft bearing) 2 pcs. (all countryside models)
- MF3512
- Draft Slide / Electrical control access Knob
- MF3513
- Fuel Stirrer (for Firepot)
- MF3514
- Fuel Stirrer driver shaft assembly
- MF3515
- Complete 24K Door Assembly (when purchased separate from unit)
- MF3516
- Fuel Stirrer Chain (specify unit model, serial number and age)
- MF3517
- Fuel Stirrer Sprocket (11-tooth sprocket on motor, 3/8” Diameter shaft)
- MF3518
- Fuel Stirrer Sprocket (11-tooth sprocket on shaft, ½” Diameter shaft)
- MF3519
- Complete Nickel Door Assembly (when purchased separate from unit)
- MF3521
- Firepot Scraper assembly (all models)
- MF3522
- Complete Black Door assembly (glass, handle, air-wash) (when purchased separate from unit)
- MF3522-CR
- Return credit for MF3522 door when traded in for another door finish or for credit
- MF3523
- Door Handle assembly (all models)
- MF3524
- Black Air-Deflector kit (Complete Assembly) (when purchased separate from unit)
- MF3526
- Door Latch shoulder bolt with ¼-20 nut
- MF3527
- Door Hinge (each) takes two (2) per unit
- MF3530
- 1 ½” Corn Feed Auger (3500P, 3500L, 3502 models)
- MF3531
- Door Glass (all models of Countryside & 7500 Corn Furnace)
- MF3535
- Stainless Steel Firepot (for 7500 Furnace models & older Countryside models)
- MF3535-B
- Stainless Steel Firepot (for all Countryside models)
- MF3536
- Auger Safety Switch
- MF3537
- Low limit / Fan Safety sensor 110 deg.
- MF3538
- Hi-Temp safety sensor 250 deg.
- MF3540
- Fuel Stirrer Motor (all models)
- MF3541
- Room Air Fan (when purchased separate from unit)
- MF3542
- Draft Blower (all models) when purchased separate from unit
- MF3549
- Fireplace Insert Shroud (when ordered separate from unit)
- P7550
- 3500P Brick Board
- MF3570
- Gold Air-Deflector kit (Complete Assembly) (when purchased separate from unit)
- MF3571
- Nickel Air Deflector kit (Complete Assembly) (when purchased separate from unit)
- MF3573
- Auger Feed Motor (all models with 1 ½” dia. Feed auger)
- MF3577
- Auger Coupler
- MF3578
- Auger Motor Gasket
- MF3592
- Millivolt Thermostats
- MF3593
- Circuit Board, Ortech (current board used on Countryside)
- MF3598
- 24K Gold Queen Ann Leg Set – 4 legs & plating (when purchased separate from unit)
- MF3599
- Nickel Queen Ann Leg Set – 4 legs & plating (when purchased separate from unit)
- MF3600
- Black Queen Ann Leg Set – 4 legs & painting (when purchased separate from unit)
- MF3601
- Ash Pan Weldment, Pedestal
- MF3609
- Installation Hardware Packet
- MF3610
- Exhaust Draft Motor Gasket (all models)
- MF3611-L
- Ash Pan for Countryside Leg Unit
- P003213
- Back Lid Assembly
- P003214
- Front Lid Assembly
- P003015
- Clean Out Slides
- P003051
- Mounting Bracket, Air Deflector
- P003053
- #8 x ½” Tek Screw ¼” Hex
- P003054
- #10-32 x 3/8” Philips Screw
- P003055
- Air Deflector Nut
- P003067
- Clean Out Rod
- P003073
- Clean-out Door
- P003080
- Rod (Hinge & Hopper Switch)
- ORDER #
- DESCRIPTION
- P6092
- Fuel stirrer retaining collar
- P003088
- ½” ID Shaft Collar
- P003099
- Auger Motor Bolt (#10-32 x 1” Hex)
- P003147
- Vibration Washers
- P003148
- #10 Washer
- P003156
- Spring Latch for Blower
- P003198
- Exhaust Tube
- P003201-W
- Exhaust Slider Weldment
- P003203
- Slider Knob (Exhaust & Circuit Board Access Door)
- P003222
- Access Door Magnetic Tape
- P003230
- Cord Connector
- P003231
- Cord
- P003232
- Wire Harness Assembly
- P003252
- Top Hinge Pin
- P003253
- Bottom Hinge Pin
- P003255
- Glass Seal Gasket
- P003257
- Glass Clips
- P7714
- Draft Slide Gate
- RP2094
- 2” Finishing Plug for Magnum Countryside Unit
- R-137
- ½” Graphite Door Seal Gasketing (priced per foot) Magnum Countryside Door
- Discontinued Countryside Parts (available for older models)
- MF3510
- Air Wash Kit (includes gasket) specify unit model, serial number (for older model countryside units)
- MF3520
- Feed Auger for J3500 1” dia. auger tube
- MF3528
- Ash Pan assembly (J3500 model) not to be used for 3500P, 3502, 3500L models
- MF3574
- Ash Pan latch assembly (J3500 model)
- MF3529
- Front Ash Pan cover (J3500 model)
- MF3532
- Power Cord (hard wired cord for older Countryside models J3500)
- MF3533
- Fan Speed Control (for models with Y1802-4 circuit board)
- MF3534
- Fuel Stirrer on/off switch (for models with Y1802-4 circuit board)
- MF3539
- Auger Feed Motor 3M-103 (J3500 models with 1” dia. Feed auger)
- CF26
- Auger Feed Motor 8 rpm (J3500 model, 3500P models with 1” dia. Feed auger) (formerly MF3572)
- MF3541-C
- Room-Air Fan (4C-447 Optional larger capacity blower) when purchased separate from unit
- MF3543
- Circuit Board retro-fit kit for older model J3500 units (from Y1802-4 to Ortech circuit board)
- MF3544
- Brick Board J3500 (for units with 1” dia. Auger (Until stock is gone, then use MF3550)
- MF3545
- Brick Board (7500 Corn Furnace) (for earlier units with 13 ½” wide Brick Board)
- MF3546
- Fuel Stirrer control board kit (for models with Y1802-4 circuit boards)
- MF3597
- Firepot Fuel Spreader w/ Bolt & Nut (used on units with replaceable fuel spreader)
- MF3612
- Combustion Enhancement System for all Model Countryside