Husqvarna HUV 4421-G / GXP - Manual (Page 49)

Battery
2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual Page 47
The battery in this vehicle is a 12-volt, low-maintenance battery that requires infrequent checks (Figure 39).
Electrolyte level should be checked semiannually.
1. Turn the key switch to the OFF position and remove the key. Place the Forward/Reverse handle in the
NEUTRAL position. Chock the wheels.
2. Access the engine compartment. See WARNING “For vehicles with cargo beds...” on page 8.
2.1. Remove the driver-side seat.
3. Disconnect the battery cables, negative (–) cable first. See WARNING “To avoid unintentionally start-
ing...” on page 9.
4. Use a flat-blade screwdriver, and carefully remove the battery cell caps from the battery. See following
WARNING.
ý WARNING
• Wear safety glasses or approved eye protection when servicing the vehicle. Wear a full face
shield and rubber gloves when working on or near batteries.
5. Carefully check the electrolyte level and add distilled water if necessary. Do not fill the battery cells above
the designated fill line. Replace battery cell caps.
6. Clean both battery terminals with a solution of baking soda and water (1 cup (237 mL) baking soda per
1 gallon (3.8 L) of water). Rinse thoroughly. Do not allow this solution to enter the battery. Tighten battery
terminals to 144 in-lb (16 N·m). Let the terminals dry and then spray them with Battery Terminal Protector
Spray (P/N 603 00 00-03). See following CAUTION.
ý WARNING
• If battery wire terminals are damaged or corroded, replace or clean them as necessary. Failure
to do so may cause them to overheat during operation and could result in a fire, property
damage, or personal injury.
Be sure the battery hold-down clight is properly tightened. Tighten to 9 ft-lb (12.2 N·m). A loose clight may
allow the battery to become damaged from vibration or jarring.
If battery appears weak, have it charged by a trained technician. The battery should never be left discharged
any longer than absolutely necessary (do not leave discharged overnight).
Figure 39 Battery Figure 40 Battery Electrolyte Level
FRONT
OF VEHICLE
NEG
POS ELECTROLYTE
LEVEL AT LEAST
1/2-INCH (13 MM)
ABOVE
PLATES OR
TO LEVEL
INDICATOR
PLATES
LEVEL
INDICATOR
BATTERY
CAP