Margaritaville NBMGLG1900 - Manual (Page 11)

-9-
TROUBLESHOOTING
PROBLEM OBSERVED
• Gas odor during set up.
• Gas odor before first ignition.
• When ignition button is pressed,
there is no spark at burner electrode.
• When igniter button is pressed,
there is spark at the electrode,
but no ignition.
• Delayed ignition.
• Burner lights but does not stay lit.
• Incorrect burner flame.
• Backfire of burner.
POSSIBLE CAUSE
• Gas leak.
• Gas leak.
• Battery dead or missing.
• Igniter electrode or switch wires
not connected or damaged.
• Broken electrode or switch wires.
• Electrode positioned improperly.
• Faulty electronic igniter.
• Electronic ignition is wet.
• Gas supply not turned on.
• Burner control knob not in
HIGH ON position.
• Air in gas lines not fully bled from system.
• Low gas pressure.
• Faulty Regulator.
• Electrode positioned improperly.
• Low gas pressure.
• Clogged or dirty burner ports.
• Blocked orifice.
• Faulty valve.
• Out of gas.
• Low gas pressure.
• Faulty valve.
• Clogged or dirty burner ports.
• Faulty regulator.
• Windy conditions.
• Out of gas.
• Incorrect gas supply or pressure.
• Incorrect primary air mix.
• Blocked orifice.
• Clogged or dirty burner ports.
• Faulty valve.
• Faulty regulator.
• High altitude.
• Blocked orifice.
• Clogged or dirty burner ports.
• Incorrect primary air mix.
CORRECTIVE MEASURE
• Refer back to Page 1 “DANGER If you
smell gas”. Check all gas connections.
• Refer back to Page 1 “DANGER If you
smell gas”. Check all gas connections.
• Replace battery.
• Reconnect or replace
electrode wires.
• Replace broken electrode or wires.
• Reposition electrode - 3/16” clearance.
• Replace electronic igniter.
• Keep ignition system dry.
• Turn on gas supply.
• Follow Operational
Instructions.
• Bleed air from system.
• Check gas supply pressure.
• Replace regulator.
• Reposition electrode - 3/16” clearance.
• Check gas supply pressure.
• Clean burner ports - see manual section.
• Check orifice opening.
• Replace valve.
• Replace propane cylinder.
• Check gas supply pressure.
• If using the hose adaptor, refer to
lighting instructions enclosed with
the hose adaptor.
• Replace valve.
• Clean burner ports - see manual section.
• Replace regulator.
• Shield from wind.
• Replace propane cylinder.
• Check gas supply pressure.
• Adjust air mixer - see manual section.
• Check orifice opening.
• Clean burner ports - see manual section.
• Replace valve.
• Replace regulator.
• Adjust orifice size for altitude.
• Check orifice opening.
• Clean burner ports - see manual section.
• Adjust air mixer - see manual section.
3 Year Limited Warranty
Sunbeam Products, Inc., doing business as Jarden Consumer
Solutions or if in Canada, Sunbeam Corporation (Canada) Limited
doing business as Jarden Consumer Solutions (collectively “Jarden
Consumer Solutions”) warrants that for a period of three years
from the date of purchase, this product will be free from defects
in material and workmanship. Jarden Consumer Solutions, at
its option, will repair or replace this product or any component
of the product found to be defective during the warranty period.
Replacement will be made with a new or remanufactured product or
component. If the product is no longer available, replacement may
be made with a similar product of equal or greater value. This is your
exclusive warranty.
This warranty is valid for the original retail purchaser from the date
of initial retail purchase and is not transferable. Keep the original
sales receipt. Proof of purchase is required to obtain warranty
performance. Jarden Consumer Solutions dealers, service centers,
or retail stores selling Jarden Consumer Solutions products do not
have the right to alter, modify or in any way change the terms and
conditions of this warranty.
This warranty does not cover normal wear of parts or damage
resulting from any of the following: negligent use or misuse of
the product, road hazards, exposure to the elements and weather,
use contrary to the operating instructions, disassembly, repair or
alteration by anyone other than Jarden Consumer Solutions or an
authorized Jarden Consumer Solutions service center. Further, the
warranty does not cover: Acts of God, such as fire, flood, hurricanes
and tornadoes.
What are the Limits on Jarden Consumer Solutions’ Liability?
Jarden Consumer Solutions shall not be liable for any incidental or
consequential damages caused by the breach of any express, implied
or statutory warranty or condition.
Except to the extent prohibited by applicable law, any implied
warranty or condition of merchantability or fitness for a particular
purpose is limited in duration to the duration of the above warranty.
Jarden Consumer Solutions disclaims all other warranties,
conditions or representations, express, implied, statutory or
otherwise.
Jarden Consumer Solutions shall not be liable for any damages of
any kind resulting from the purchase, use or misuse of, or inability
to use the product including incidental, special, consequential or
similar damages or loss of profits, or for any breach of contract,
fundamental or otherwise, or for any claim brought against
purchaser by any other party.
Some provinces, states or jurisdictions do not allow the exclusion
or limitation of incidental or consequential damages or limitations
on how long an implied warranty lasts, so the above limitations or
exclusions may not apply to you.
This warranty gives you specific legal rights, and you may also have
other rights that vary from province to province, state to state or
jurisdiction to jurisdiction.
How to Obtain Warranty Service
If you have any question regarding this warranty or would like
to obtain warranty service, please call 1-877-689-2737 and a
convenient service center address will be provided to you.
In the U.S.A., this warranty is offered by Sunbeam Products, Inc.,
doing business as Jarden Consumer Solutions, located in Boca
Raton, Florida 33431.
PLEASE DO NOT RETURN THIS PRODUCT TO ANY OF THESE
ADDRESSES OR TO THE PLACE OF PURCHASE.
134912 Rev SUB