Ice-O-Matic CD20030 CD20530 - Manual (Page 15)

CD10022 CD20030
CD10522 CD20530
Cleaning
General Care and Ceaning:
Periodically inspect and clean the ice dispenser
to keep it operating at peak performance.
Wash the outside of the dispenser with warm
water and soap. Rinse off and dry.
Cleaning and Sanitizing of the Ice
Storage Bin:
The minerals, chlorine and other impurities in the
water are rejected from the water during the
freeze cycle of the ice machine. These minerals
will collect in the storage bin. The ice storage bin
should be cleaned and sanitized every 90 days.
1. Remove all of the ice stored inside the
dispenser bin by holding in dispensing button
and shut off the ice maker.
2. Disconnect the electrical power.
3. Locate key and remove front panel.
4. Remove top front panel (in front of ice machine)
5. Reach into the opening, locate the
sweep arm securing the wheel to the
drive shaft. Remove the sweep arm
by rotating it in the counter clockwise
direction.
6. Pull the wheel off the drive shaft and
leave it in the dispenser.
7. Mix a solution of 5 ounces of ice
machine cleaner to 1 gallon of warm
(95
o F-115 o F) water. Rubber gloves
and eye protection to be worn. Wash
the entire bin area and the delivery
area. Use a clean brush or cloth.
8. Rinse all areas washed with clean,
fresh water.
9. Using the ice machine cleaning
solution, clean the ice grill, sink, and
water pan. Rinse these parts with
clean, fresh water.
13
Ice machine cleaner
contains acids.
These compounds
may cause burns.
If swallowed, DO NOT
induce vomiting. Give
large amounts of water
or milk. Call physician
immediately! In case of
external contact, flush
with water.
KEEP OUT OF THE
REACH OF CHIL-
DREN!
Electrical shock hazard.
Electrical shock can
cause personal injury.
Disconnect power before
begining to service
components.
Moving parts in bin will
cause injury if hands
are in the way.
disconnect electrical
power before begining
procedures.