Sea Frost DC 5000 User Manual
Sea Frost Refrigerators
Advertising
1
372 ROUTE 4 BARRINGTON, NH 03825 USA
TEL (603) 868-5720
FAX (603) 868-1040
1-800-435-6708
E-Mail:[email protected]
www.seafrost.com
DC 5000 SYSTEM 134a
OPERATION & INSTALLATION
INSTRUCTIONS
NOTICE OF RESPONSIBILITY
It is the SEA FROST/C.F. Horton & Co., Inc. intent to provide the safest, most accurate
and detailed instructions. SEA FROST/C.F. Horton & Co.,Inc. cannot be responsible for
problems or damage caused by omissions, inaccuracy or interpretation of these
instructions.
SEA FROST is a registered trademark of C.F. Horton & Co.,Inc
Aspects of the SEA FROST design are covered by
US Patent #4,356,708
2nd Edition
134 12 volt
Copyright © 1996 by C.F. Horton & Co., Inc.
Advertising
Table of contents
Document Outline
- START UP PROCEDURE AND PERIODIC INSPECTION
- GENERAL DESCRIPTION
- OPERATION
- ICE MAKING
- MAINTENANCE
- INSTALLATION
- TUBE HANDLING
- INSTALLING THE DC 5000 COMPRESSOR UNIT
- WATER PUMP INSTALLATION AND WATER CIRCUIT
- PLATE LOCATION
- VALVE UNIT V/U
- NOTES ON SWAGELOK FITTINGS
- RECONNECTING PRE-SWAGED FITTINGS
- RUNNING THE LINES
- POSITIONING THE RFD
- RFD (Receiver Filter Drier)
- INSULATING THE LINES
- ELECTRICAL SYSTEM
- THERMOSTAT CONTROL PANEL LOCATION
- ELECTRICAL JUNCTION BOX
- WIRE SIZES
- FUSES
- WIRING
- ASSEMBLY INSPECTION CHECK LIST
- REFRIGERANT HANDLING AND SAFETY
- PROCEDURES FOR WORKING WITH R-134a
- ACCESS TO THE SYSTEM: SERVICE ACCESS PORTS
- GAUGES
- COMMISSIONING PROCEDURE
- NEW SYSTEM CHARGING
- LEAK CHECKING A CHARGED SYSTEM
- READING THE SIGHT GLASS
- PROPER CHARGE AMOUNT
- DISCHARGING THE SYSTEM
- TROUBLESHOOTING
- PRESSURE CHARTS
- DC 5000 MOTOR AND WATER PUMP MAINTENANCE
- DC5000 WIRING
- DC 5000 LAYOUT
- DC 5000 WATER CIRCUIT
- TWIN VALVE SYSTEMS ONLY
- DC 5000 Low Voltage Protection Relay