Lincoln Electric 11395 - Manual (Page 10)

FUEL
Fill the fuel tank with clean, fresh, lead-free gasoline.
Observe fuel gauge while filling to prevent overfilling.
OIL
The RANGER 10,000 PLUS AND RANGER 10,000 is
shipped with the engine crankcase filled with SAE
10W-30 oil. Check the oil level before starting the
engine. If it is not up to the full mark on the dip stick,
add oil as required. Make certain that the oil filler cap
is tightened securely. Refer to the engine Owner’s
Manual for specific oil recommendations.
BATTERY CONNECTIONS
Use caution as the electrolyte is a strong
acid that can burn skin and damage eyes.
-----------------------------------------------------------------------
This welder is shipped with the negative battery cable
disconnected. Make sure that the Engine Switch is in
the “STOP” position and attach the disconnected
cable securely to the negative battery terminal before
attempting to operate the machine. If the battery is
discharged and does not have enough power to start
the engine, see the battery charging instructions in the
Battery section.
NOTE: This machine is furnished with a wet charged
battery; if unused for several months, the battery may
require a booster charge. Be careful to charge the bat-
tery with the correct polarity.
3. Proper placement of the equipment on the trailer to
insure stability side to side and front to back when
being moved and when standing by itself while
being operated or serviced.
4. Typical conditions of use, i.e., travel speed; rough-
ness of surface on which the trailer will be operated;
environmental conditions.
5. Conformance with federal, state and local laws (1)
(1) Consult applicable federal, state and local laws regarding specific
requirements for use on public highways.
A-3 INSTALLATION
RANGER 10,000 PLUS AND RANGER 10,000
A-3
PRE-OPERATION SERVICE
READ the engine operating and maintenance
instructions supplied with this machine.
CAUTION
LUBRICATION SYSTEM CAPACITY
(INCLUDING FILTER)
Kohler CH23S - 2.0 Quarts (1.9 Liters)
Subaru Robin EH65-1.6 Quarts (1.6 Liters)
Honda GX620KI-1.9 Quarts (1.8 Liters)
• Damage to the fuel tank may cause
fire or explosion. Do not drill holes
in the RANGER 10,000 PLUS AND
RANGER 10,000 base or weld to the
RANGER 10,000 PLUS AND
RANGER 10,000 base.
-----------------------------------------------------------------------
WARNING
CAUTION
• Stop engine while fueling.
• Do not smoke when fueling.
• Keep sparks and flame away
from tank.
• Do not leave unattended while
fueling.
• Wipe up spilled fuel and allow
fumes to clear before starting
engine.
• Do not overfill tank, fuel expan-
sion may cause overflow.
GASOLINE FUEL ONLY
------------------------------------------------------------------------
WARNING
GASOLINE
can cause fire
or explosion.
VEHICLE MOUNTING
Improperly mounted concentrated loads may
cause unstable vehicle handling and tires or other
components to fail.
• Only transport this Equipment on serviceable
vehicles which are rated and designed for such
loads.
• Distribute, balance and secure loads so vehicle
is stable under conditions of use.
• Do not exceed maximum rated loads for compo-
nents such as suspension, axles and tires.
• Mount equipment base to metal bed or frame of
vehicle.
• Follow vehicle manufacture’s instructions.
------------------------------------------------------------------------
WARNING