Lincoln Electric INVERTEC V350-PRO IM679-A - Manual (Page 9)

A-2 INSTALLATION A-2
SELECT SUITABLE LOCATION
The Invertec V350-PRO will operate in harsh environ-
ments. Even so, it is important that simple preventa-
tive measures are followed in order to assure long life
and reliable operation.
• The machine must be located where there is free cir-
culation of clean air such that air movement in the
back, out the sides and bottom will not be restricted.
• Dirt and dust that can be drawn into the machine
should be kept to a minimum. Failure to observe
these precautions can result in excessive operating
temperatures and nuisance shutdown.
• Keep machine dry. Shelter from rain and snow. Do
not place on wet ground or in puddles.
• DO NOT MOUNT OVER COMBUSTIBLE SURFACES.
Where there is a combustible surface directly under
stationary or fixed electrical equipment, that surface
shall be covered with a steel plate at least
.06
” (1.6mm) thick, which shall extend not less than
5.90 ” (150mm) beyond the equipment on all sides.
STACKING
V350-PRO cannot be stacked.
TILTING
Place the machine directly on a secure, level surface
or on a recommended undercarriage. The machine
may topple over if this procedure is not followed.
INPUT AND GROUNDING CONNECTIONS
• Only a qualified electrician should connect the
Invertec V350-PRO. Installation should be made in
accordance with the appropriate National Electrical
Code, all local codes and the information detailed
below.
• When received directly from the factory, multiple
voltage machines are internally connected for
460VAC. If 460VAC is the desired input, then the
machine may be connected to the power system
without any setup required inside the machine.
• Initial 200VAC - 415VAC and 575VAC operation will
require an Input voltage panel setup.
SAFETY PRECAUTIONS
ELECTRIC SHOCK can kill.
• TURN THE INPUT POWER OFF AT
THE DISCONNECT SWITCH BEFORE
ATTEMPTING TO CONNECT OR DIS-
CONNECT INPUT POWER LINES, OUTPUT
CABLES, OR CONTROL CABLES.
• Only qualified personnel should perform this
installation.
• Connect the green/yellow lead of the power
cord to ground per U.S.National Electrical
Code.
----------------------------------------------------------------------
WARNING
• Initial 200VAC - 415VAC and 575VAC operation will
require an Input voltage panel setup.
• Open the access panel on the rear of the machine.
• For 200 or 230: Position the large switch to 200-
230.
For higher voltages: Position the large switch to
380-575.
• Move the "A" lead to the appropriate terminal.
POWER CORD CONNECTION
A 10 ft. power cord is provided and wired into the
machine. Follow the power cord connection instruc-
tions.
• Incorrect connection may result in equipment
damage.
-----------------------------------------------------------------------
Single Phase Input
Connect green lead to ground per National Electrical
Code.
Connect black and white leads to power.
Wrap red lead with tape to provide 600V insulation.
Three Phase Input
Connect green lead to ground per National Electric
Code.
Connect black, red and white leads to power.
CONNECTIONS OF WIRE FEEDERS TO V350-PRO
LN-25 Connection Instructions
(Factory, Construction &
Advance Process versions
can be connected.-Not recommended for Pulse
Welding in the Advance Process version).
• Turn the Invertec power switch "off".
• Connect the electrode cable to the output terminal of
polarity required by electrode. Connect the work lead to
the other terminal.
• LN-25 with Remote Control options can be used with the
K1728-1 and K1728-4 versions of the V350. The 6-Pin
(K444-1) and 14-pin (K444-2) remotes can be connected
directly to the 6-pin & 14-pin MS-style connectors. The 42
Volt Remote Voltage and Output Control (K624-1) Kit can
be connected to the V350
’ s 24/42 VAC connector using
Remote Control Cable assembly K627- [ ]. LN-25s with a
K431-1 remote kit can be connected to the V350
’ s 24/42
VAC connector using a K432 cable and K876 adapter.
(See connection diagram S19899). Or the K432 cable
could be modified with a K867 Universal Adapter Plug
(See connection diagram S19405) to connect it to the
V350 ’ s 24/42 VAC connector.
W AR NIN G RE M OT E
PO W ER
OF F
ON
A AMPS
A
V VOLT S
W EL D TE RM IN AL S SE LE CT
OUTPUT LINCOLN ELECTRIC
INV ERT EC V35 0-PR O
W AR NIN G W AR NIN G AV ISO DE PR EC AU CION
ATT EN TI ON
!
!
!
!
Lore m ips um dolo r sit am et c ons ecte tuer adi pisc ing Lore m ip sum dolo r sit am et c ons ecte tue r ad ipis cing elit, ed dia m no n elit, ed dia m n onu mm um my nib h eu ism od tinc idu nt ut y n ibh eu ism od t incid unt ut lao ree t do lore ma gn a al iqu am er lao ree t do lore ma gna aliq uam erata t Lor em ipsu m dolo r sit am et c on sec tetu er a dip iscin g Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed d iam non elit, ed d iam no num m um my nib h eu ism od tinc idu nt ut y n ibh eu ism od t incid unt ut lao ree t do lore mag na aliqu am er laor eet dolo re m agn a a liqu am erat at Lore m ipsu m d olor sit a me t co ns ec tetue r ad ipis cing Lore m ipsu m dolo r sit am et c ons ecte tue r ad ipis cing elit, ed dia m non elit, ed dia m non um m um my nib h eu ism od tinc idu nt ut y n ibh eu ism od tinc idu nt u t laor eet dolo re ma gn a a liqu am er lao ree t do lore m agn a a liqu am era t at Lo rem ipsu m d olo r sit am et c ons ecte tue r ad ipis cing Lore m ipsu m d olo r sit am et c ons ecte tue r ad ipis cing elit, ed dia m non elit, ed dia m n onu mm um my nib h e uism od tinc idu nt ut y n ibh eu ism od t incid unt ut lao reet do lore ma gn a a liqua m er lao ree t do lore m agn a a liqu am era t at Lo rem ipsu m dol or s it a me t con sec tetue r adi pisc ing
Lore m ip sum do lor sit a me t co nse cte tue r ad ipis cing elit, ed dia m non elit, ed d iam no num m um my nib h e uism od t incid unt ut y n ibh eu ism od t incid unt ut lao ree t dol ore ma gna aliq ua m er lao ree t do lore ma gna aliq uam era t at Lor em ipsum dolo r sit am et con sec tetu er a dip iscin g
Lore m ipsu m dolo r sit am et c ons ecte tue r ad ipis cin g elit, ed dia m no n elit, ed dia m n onu mm um my nib h e uism od tinc idu nt ut y n ibh eu ism od t incid unt ut lao ree t do lore ma gna aliq ua m er lao ree t do lore ma gna aliq uam era t at Lo rem ips um dolor sit am et c ons ecte tue r ad ipis cing Lore m ipsu m d olo r sit am et c ons ecte tue r ad ipis cing elit, ed dia m non elit, ed d iam no num m um my nib h e uis mo d tin cidu nt ut y n ibh eu ism od t incid unt ut lao ree t dol ore ma gna aliq ua m er lao ree t do lore m agn a a liqu am era t at Lore m ipsu m dol or s it a me t co ns ecte tue r ad ipis cing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing eli t, e d d iam non elit, ed d iam no num m um my nibh euis mo d tin cidu nt u t y n ibh eu ism od t incid unt ut laor eet dolo re ma gna aliqu am er lao reet do lore ma gna aliq uam era t at Lore m ipsu m dolo r sit am et con sec tetu er adi pisc ing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit , ed dia m non elit, ed dia m n onu mm um my nib h e uism od tinc idu nt ut y n ibh euis mo d tin cidu nt u t lao ree t do lor e m ag na aliqu am er lao ree t do lore m agn a a liqu am erat at
Lor em ipsu m dolo r sit am et con sec tetue r ad ipis cin g Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed diam no n elit, ed d iam no num m um my nibh eu ism od tinc idu nt u t y n ibh euis mo d tin cidu nt u t lao reet dolo re ma gn a a liqu am er lao ree t do lore m agna aliqu am era t at Lorem ipsu m dolo r sit am et cons ec tetu er a dipi scin g Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed dia m non elit, ed dia m non um m um my nib h e uism od tinc idun t ut y n ibh euis mo d tin cidu nt u t
lao reet do lor e m ag na aliq uam er lao ree t do lore m agn a a liqu am era t at Lo rem ipsu m dolor sit am et c ons ectet uer adip iscin g Lore m ip sum do lor s it a me t co nsec tetu er a dip iscin g elit, ed dia m non elit, ed d iam no num m um my nib h e uism od tinc idu nt u t y n ibh euis mo d tin cidu nt u t lao ree t do lor e m ag na aliq uam er lao ree t do lore m agn a a liqu am era t at Lore m ips um dol or s it a me t co ns ec tetu er a dipi scin g
Lore m ipsu m dolo r sit am et c ons ecte tue r ad ipis cing eli t, e d d iam non elit, ed d iam no num m um my nib h e uism od tinc idun t ut y n ibh eu ism od t incid unt ut lao ree t dol ore ma gn a a liqu am er lao ree t do lore m agn a a liqu am era t at Lo rem ipsu m dolo r sit am et con sec tetu er a dip iscing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
elit , ed diam non elit, ed d iam no num m um my nib h e uismo d tin cidun t ut y n ibh euis mo d tin cidu nt u t
laor ee t do lore ma gna aliqu am er laor eet dolo re m agn a a liqu am erat Lo rem ips um do lor sit amet consec tetuer adipis cing
Lore m ip sum do lor s it a me t con sec tetu er a dip iscin g
elit, ed diam non elit, ed dia m n onu mm um my nibh euis mo d tinc idun t ut y n ibh eu ism od t incid unt ut
lao ree t do lore ma gna aliq ua m er lao ree t do lore m agn a a liqu am erata t Lor em ipsum dolo r s it a me t con sec tetu er a dipi scin g
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
elit , e d d iam non elit, ed d iam no num m um my nibh eui sm od tinc idunt ut y nib h e uism od t incid unt ut
laor eet do lor e m agn a al iqu am er lao ree t do lore m agn a al iqu am era t at Lo rem ipsum dolo r sit amet con sec tetu er ad ipis cin g
Lore m ip sum dolo r sit am et c ons ecte tue r ad ipis cing
elit, ed diam no n elit, ed dia m n onu mm um my nib h e uis mo d tin cid un t u t y n ibh euis mo d tin cidu nt u t
lao ree t dolo re m agn a a liq ua m er lao ree t do lore ma gna aliq uam erat at
Lore m ipsum do lor sit a me t co nse cte tue r ad ipis cing Lore m ip sum do lor sit a me t co nse cte tue r ad ipis cing elit, ed dia m no n elit, ed dia m n on um m um my nib h e uism od tinc idu nt ut y n ibh eu ism od tinc idu nt u t laor eet dol ore ma gna aliq uam er lao ree t do lore m agn a a liqu am era t at Lo rem ipsu m do lor sit a met con sec tetu er ad ipis cing Lore m ipsu m dolo r sit am et c ons ecte tue r ad ipis cing elit , ed dia m non elit, ed d iam no num m um my nib h eu ism od tinc idu nt u t y n ibh euis mo d tin cidu nt u t laor eet dolo re ma gna aliq uam er lao ree t do lore m agn a a liqu am era t at
GREEN
RED
BLACK
WHITE
V350-PRO
CAUTION
CAUTION