Thermos EXPRESS 06401314 - Manual (Page 4)

Use and Care
LP (Liquefied Petroleum Gas)
• For Your
Safety
• LP gas is highly flammable and may ignite unexpectedly
when mixed with air.
Is nontoxic, odorless and colorless when produced.
, LP gas has been given an odor (similar to rotten
cabbage) so that it can be smelled.
Propane Cylinder Use (1 lb. Disposable)
•
•
•
•
•
Use only cylinder marked “Propane Fuel”.
Cylinder must be constructed and marked in accordance with
the specifications for LP-gas cylinders of the U.S. Department
of Transportation (DOT) or the National Standard of Canada,
CAN/CSA-B339, Cylinders, Spheres and Tubes for the
Transportation of Dangerous Goods.
Size should be 4” diameter, 8” height, or 3” diameter, 10”
height.
Save cylinder cap and reinstall when not in use.
Cylinder supply system must be arranged for vapor
withdrawal. Gas cylinder must be upright in use.
Leak Testing (1 lb. Disposable)
• During leak test, keep grill away from open flames or sparks
and do not smoke. Grill must be leak tested outdoors in a well
ventilated area.
Leak test must be repeated each time gas cylinder is replaced
or after storage.
Materials needed include clean paint brush and 50/50 soap and
water solution. Use mild soap and water.
Damage to components can
result.
Be sure on regulator is in "OFF" position.
Brush soapy solution onto between gas cylinder
and regulator at .
•
Do not use
household cleaning agents.
1. control knob
2. connection
(A)
IMPORTANT!
If growing bubbles appear, there is a leak. Retighten
connection and repeat steps 1 and 2.
If you cannot stop a leak, remove gas
cylinder from regulator and check for
damaged threads, dirt and debris on
regulator and gas cylinder. Also check to
see if anything is obstructing flow of gas at
regulator and gas cylinder openings.
Remove any obstruction that may be
found and repeat leak test.
Order new parts by
giving the serial, model number and name
of items needed to the Grill Service Center
at
.
If threads are
damaged on either regulator or gas
cylinder, replace.
1-800-232-3398
A
WARNING
For Safe Use of Your Grill and to Avoid Serious
Injury:
• Apartment Dwellers:
•
.
•
•
•
•
•
• Use grill at least 3 ft. from any wall or surface.
• NEVER attempt to light burner with lid closed. A
buildup of non-ignited gas inside a closed grill is
hazardous.
• Never operate grill with LP cylinder out of correct
position specified in assembly instructions
Do not let children operate or play near grill.
Keep grill area clear and free from materials that burn (i.e.
gasoline, propane, or any other flammable liquid or gas).
Do not block holes in bottom or back of grill.
Check burner flames regularly.
• Never use regulator from this grill with any other LP
appliance.
• When cooking, the appliance must be on a level surface in
an area clear of combustible material.
Use grill only in well-ventilated space. NEVER use in
enclosed space such as carport, garage, porch, covered
patio, or under an overhead structure of any kind.
Do not use charcoal or ceramic briquets in a gas grill.
(
• This appliance is not intended for and should never be used
as a heater.
Maintain
10 ft. clearance to objects that can catch fire or sources of
ignition such as pilot lights on water heaters, live electrical
appliances, etc..
Check with management to learn the requirements and fire
codes for using an LP gas grill in your apartment complex.
If allowed, use outside on the ground floor with a three (3)
foot clearance from walls or rails. Do not use on or under
balconies.
Unless briquets are supplied with your grill.)
A
3 ft. (1m) minimum
10 ft. recommended
4 • 06401314