Thermos EXPRESS 06401314 - Manual (Page 5)

06401314 • 5
CAUTION
If ignition does NOT occur in 5 seconds, turn the
burner controls OFF, wait 5 minutes and repeat the
lighting procedure. If the burner does not ignite with
the valve open, gas will continue to flow out of the
burner and could accidently ignite with risk of injury.
DANGER
• NEVER store a spare cylinder under or near the
appliance or in an enclosed area.
• Never fill a cylinder beyond 80% full.
• An overfilled or improperly stored cyclinder is a hazard
due to possible gas release from the safety relief valve.
This could cause an intense fire with risk of property
damage, serious injury or death.
• If you see, smell or hear gas escaping, immediately get
away from the LP cylinder/appliance and call your fire
department.
Safety Tips
The use of alcohol, prescription or nonprescription drugs
may impair the consumer’s ability to properly assemble or
safely operate the appliance.
When grill is not in use, disconnect 1 lb. cylinder.
Never move grill while in operation or still hot. Allow the
appliance to cool before moving or storing.
Use only tools supplied or plastic tools.
Maximum load for side shelves is 10 lbs.
The regulator may make a humming or whistling noise
during operation. This will not affect safety or use of grill.
If you have a grill problem see the Troubleshooting Section.
Light burners. Check to make sure they are lit, close the lid
and warm up grill on high for 2
0 minutes. Curing of paint
and parts will produce an odor only on first lighting.
Grill is not to be used as a heater.
Ignitor Lighting
Do not lean over grill while lighting.
1. Open lid during lighting.
2.
3.
4.
5.
6.
Make sure LP cylinder is properly
connected to regulator.
Turn LEFT knob to .
Turn rotary ignitor knob (up to 5 times) to light. Be sure
burner lights and stays lit.
If ignition does NOT occur in 5 seconds, turn the burner
controls OFF, wait 5 minutes and repeat the lighting
procedure.
To ignite RIGHT burner, turn right knob to and repeat
steps 3-4.
If IGNITOR does not work, follow match lighting instructions.
Turn controls OFF and disconnect cylinder when not
in use.
WARNING
Normal
Hose Kinked
Hose
Before Your First Cookout.
Turning Grill Off
Leak test your grill L .ight burners, check to make sure they are
lit, close the lid and warm up grill on HIGH for 10 minutes. Curing
of paint and parts will produce an odor only on first lighting.
• Turn knobs to OFF position. Make sure knobs pop up. If it
does not, discontinue use and order new part.
• Disconnect 1 lb. Cylinder.
Hose Check
• Before each use, check to see if
hoses are cut, worn or kinked.
Replace damaged hoses before
using grill. Use only
valve/hose/regulator specified by
manufacturer.
Match Lighting
1. Attach match to match lighting stick, light match.
2. Insert lit match through grate and next to burner. Turn gas on
for appropriate burner. Repeat for other burner.
Match
lighting
stick