Wells WFAE-30F - Manual (Page 12)

PREPARATION PRIOR TO OPERATION (continued)
10
Fill the FRYPOT to the COLD (MAX) line on OIL LEVEL INDICATOR
with room temperature commercial-quality LIQUID SHORTENING.
This requires 30lbs. of oil.
Check operation of FRYER and all CONTROLS.
DETERMINE MAXIMUM LOAD WEIGHT:
For operational safety, it is very important to determine the maximum
load weight for the specific operation. This can be accomplished by
starting out with small loads and gradually increasing to the largest
load size that will allow a cook cycle to be completed without oil
foaming out of the FRYPOT.
NOTE:
Fill frypot with 30 lbs of
LIQUID SHORTENING
ONLY.
DO NOT USE
• SOLID SHORTENING
• LARD
Solid shortening will solidify in
the filter reservoir and filter
pump rendering the filtration
system inoperable.
Damage caused the use of
anything other than liquid
shortening is NOT COVERED
BY WARRANTY.
IMPORTANT:
For operational safety it is
important to determine the
maximum load weight for the
specific operation:
• Start with small loads
• Gradually increase load
size
• Determine the largest load
that will allow a full cook
cycle without oil foaming
out of the frypot.
• Post the maximum load in a
conspicuous spot near the
fryer.
WARNING:
OIL SPLATTER HAZARD
The weight of product that can safely be cooked in this pressure fryer
will vary with oil level, product moisture content and oil temperature.
FAILURE TO DETERMINE THE SAFE WEIGHT OF PRODUCT
WILL RESULT IN HOT OIL RELEASE FROM THE FRYER
HOT OIL WILL CAUSE SEVERE BURNS ON CONTACT
Death or serious injury may result from slipping and falling in spilled oil.
WARNING
361
301
669
OpM
anual
for
W
F
A
E
-30
F
Ele
c
tric Fr
yer
COOK HEAT POWER POWER
FRYER OFF FILTER FILTER
WELLS
300 325 350 THERMOSTAT FILTER ON
OFF CAUTION
FRYER MUST BE OFF
BEFORE USING FILTER CAUTION
FRYER MUST BE OFF
BEFORE USING FILTER
DRAIN
VALVE
FILTER
RESERVOIR
250 275 375
ºF
HI-LIMIT RESET DRAIN
VALVE
LEVER
UPPER CONTROL PANEL
COOK HEAT POWER
WELLS
FRYER
OFF
FILTER
LOWER CONTROL PANEL
RESET
FILTER THERMOSTAT
ºF
ON
OFF
HI-LIMIT 250
275
300 325
350
375
CAUTION FRYER MUST BE OFF
BEFORE USING FILTER
B
U
Z Z E R
POWER SWITCH ( ) FILTER-OFF-FRYER
SET
COOK
TIME
START
COOK
CYCLE
SET COOK
TEMPERATURE
RESET HI-LIMIT
FILTER PUMP
SWITCH
DRIP
PAN
MAX (COLD)
30 LB. 13KG OIL LEVEL
MIN (HOT)
OIL LEVEL INDICATOR