GE Industrial Solutions CAR2548TN series - Manual (Page 2)

GE Energy
CAR2548TN series rectifier
Input: 90Vac to 264Vac; Output: -54 Vdc @ 2500W; 3.3Vdc or 5 Vdc @ 1A
April 23, 2013 ©2012 General Electric Company. All rights reserved. Page 2
Absolute Maximum Ratings
Stresses in excess of the absolute maximum ratings can cause permanent damage to the device. These are absolute stress ratings only, functional
operation of the device is not implied at these or any other conditions in excess of those given in the operations sections of the data sheet.
Exposure to absolute maximum ratings for extended periods can adversely affect the device reliability.
Parameter Device Symbol Min Max Unit
Input Voltage: Continuous All VIN 0 264 Vac
Operating Ambient Temperature All TA -10 70 1 °C
Storage Temperature All Tstg -40 85 °C
I/O Isolation voltage (100% factory Hi-Pot tested) All 1500 Vdc
Electrical Specifications
Unless otherwise indicated, specifications apply over all operating input voltage, load, and temperature conditions.
INPUT
Parameter Device Symbol Min Typ Max Unit
Operational Range All V
IN
90 110/230 264 V
ac
Frequency Range (ETSI 300-132-1 recommendation) All F
IN 47 50/60 63 Hz
High Line Operation 180 – 264 Vac All
W
0 - 2500 W
Low Line Operation 90 – 132 Vac All W 0 - 1200 W
Main Output Turn_OFF All V
IN 85 V
ac
Maximum Input Current V
IN
= 90Vac
All I
IN
16
16
A
ac
(V
O
= V
O, set
, I
O
=I
O, max
) V
IN
= 180Vac
Cold Start Inrush Current
All I
IN
50 A
peak
(Excluding x-caps, 25C, <10ms, per ETSI 300-132)
Efficiency
All  92 %
(T
amb
=25C, V
in
= 230Vac, V
out
= 54Vdc)
Power Factor
(V
in
=230Vac, I
O
=I
O, max
)
All
PF 0.99
Holdup time
(V
in
= 230Vac, V
out
= -54V
dc
, T
amb
25C, I
O
=I
O, max
)
All T 16.8 ms
Loss of Output Early Warning Signal 2 ms
Ride through All T 8.3 ms
Leakage Current
(V
in
= 250Vac, F
in
= 60Hz)
All
I
IN
3 mArms
Isolation Input/Output
All
3000 V
ac
Input/Frame 1500 V
ac
Output/Frame 100 V
dc
-54V
dc
MAIN OUTPUT
Parameter Device Symbol Min Typ Max Unit
Output power All P
out
0 2500 W
dc
Set point All
V
out
-53.94 -54.00 -54.06 V
dc
Overall regulation (load, temperature, aging) All -2 +2 %
Ripple and noise 2 All 540 mV
p-p
Turn-ON overshoot All +3 %
Turn-ON delay All T 2 sec
1 Derated above 50C at 2.5%/C
2 Measured across a 10µf electrolytic and a 0.1µf ceramic capacitors in parallel. 20MHz bandwidth