Vestil LLW-PAILD-200 - Manual (Page 6)

01/06 42-126-120
V ESTIL M FG . C O . 6
T ROUBLESHOOTING G UIDE -- LLW-PAILD-200
Warning: Before performing any task, always lower the pail dumper fully to the floor and remove the pail.
Consult the factory for any problems not addressed below.
Problem: Possible cause(s): Action:
The pail carrier will not raise or
is very difficult to raise.
Too much load in the carrier.
The cable has come off the upper pulley.
One or more guide rollers has seized.
The guide rollers are bound up by an
obstruction in, or damage to, the guide track.
Remove some of the pail’s contents.
Rotate the winch crank counterclockwise one
full turn after the carrier is lowered to the
floor. Reinstall the cable into the upper
pulley’s groove. Rotate the winch clockwise
to wind the slack cable back onto the spool.
Lubricate or replace the roller(s).
Inspect for damage to the roller guide track.
Repair or lubricate as necessary.
The pail carrier will not lower. Same as the previous two line items, above.
Not enough load on the winch.
Winch is bound up.
Same as above.
Lubricate the roller guide track. Pull or push
down on the pail carrier as the crank
handle is turned counterclockwise.
Repair or replace the winch. Consult factory.
The pail carrier will not rotate. Something has caused the pivot point(s) to
seize.
Check for corrosion or hardened material
buildup at the carrier saddle’s pivoting
points.
The pail carrier travels the
wrong direction when the
winch handle is turned
clockwise.
Cable is wound backwards around the winch
drum.
Rotate the crank handle to unspool all the
cable from the winch. Continue rotating
the handle in the same direction until all
the cable slack is taken up on the spool.
The pail carrier’s saddle strap
will not stay tight.
Worn web strap.
Worn or damaged strap ratchet.
Ratchet strap release mechanism is stuck in the
“release” position.
Replace the strap and ratchet assembly.
Same as above.
Inspect for and eliminate the cause of the
release mechanism sticking. If damaged,
replace the strap and ratchet.
The pail carrier will not lock
into a rotated position.
The locking mechanism is stuck in the “release”
position.
Inspect the locking mechanism for damage,
bowing, or buildup of material that could
be causing it to stick. Take the
appropriate steps to correct the problem
found.
P RODUCT W ARRANTY
90-DAY LIMITED WARRANTY
The manufacturer warrants for the original purchaser against defects in materials and workmanship under normal use
for 90 days after date of shipment. Any part that is determined by the manufacturer to be defective in material or
workmanship and returned to the factory, shipping costs prepaid, will be, as the exclusive remedy, repaired or
replaced at our option. Labor costs for warranty repairs and/or modifications are not covered unless pre-approved by
the manufacturer or done at the manufacturer’s facilities. Any modifications performed without prior written approval
of the manufacturer may void warranty. This limited warranty gives purchaser specific legal rights which vary from
state to state.
All specifications are subject to change without notice.
LIMITATION OF LIABILITY
To the extent allowable under applicable law, the manufacturer’s liability for consequential and incidental damages is
expressly disclaimed. The manufacturer’s liability in any event is limited to, and shall not exceed, the purchase price
paid. Misuse or modification may void warranty.
Warranty does not cover labor or consequential damages including, but not limited to, business interruption costs, lost
profits, or lost business opportunities.
WARRANTY DISCLAIMER
The manufacturer has made a diligent effort to accurately illustrate and describe their products. However, such
illustrations and descriptions are for the sole purpose of identification, and do not express or imply a warranty that the
products are merchantable or fit for a particular purpose, or that the products will necessarily conform to the
illustrations or descriptions.
The provisions of the warranty shall be construed and enforced in accordance with the Uniform Commercial Code and
laws as enacted in the State of Indiana.
DISPOSITION
Our company will make a good faith effort for prompt correction or other adjustment with respect to any product that
proves to be defective within the Limited Warranty Period. Warranty claims must be made in writing within said year.