Blodgett KTC-G Series - Manual (Page 3)

OM-KTT/KTC-G 1
IMPORTANT - READ FIRST - IMPORTANT
WARNING: FAILURE TO DISCONNECT POWER BEFORE SERvICING COULD RESULT IN ELECTROCUTION
AND DEATH.
WARNING: IMPROPER INSTALLATION, ADjUSTMENT, ALTERATION, SERvICE OR MAINTENANCE CAN
CAUSE PROPERTY DAMAGE, INjURY OR DEATH. READ THE INSTALLATION, OPERATING AND
MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING OR SERvICING THIS
EqUIPMENT.
WARNING: THE UNIT MUST BE INSTALLED BY PERSONNEL qUALIFIED TO WORK WITH GAS, ELECTRICITY
AND PLUMBING. UNIT MUST BE INSTALLED IN ACCORDANCE WITH ALL APPLICABLE CODES.
WARNING: DO NOT ATTACH THE UNIT TO A TYPE “B” vENT. IT COULD CAUSE FIRE OR PROPERTY DAMAGE.
WARNING: DO NOT CONNECT ANY PIPING TO THE PRESSURE RELIEF vALvE. IT MUST BE FREE TO vENT
STEAM AS NEEDED. TO AvOID BURNS FROM THE vENTED STEAM THE vALvE DISCHARGE
SHOULD POINT DOWNWARD.
DANGER: ELECTRICALLY GROUND THE UNIT AT THE TERMINAL PROvIDED. FAILURE TO GROUND THE
UNIT COULD RESULT IN ELECTROCUTION AND DEATH.
CAUTION: BE SURE ALL OPERATORS READ, UNDERSTAND AND FOLLOW THE OPERATING INSTRUCTIONS,
CAUTIONS AND SAFETY INSTRUCTIONS CONTAINED IN THIS MANUAL.
CAUTION: DO NOT OvERFILL THE KETTLE WHEN COOKING, HOLDING OR CLEANING. KEEP LIqUIDS
A MINIMUM OF 2-3” (5-8 CM) BELOW THE KETTLE BODY RIM TO ALLOW CLEARANCE FOR
STIRRING, BOILING AND SAFE TRANSFER OF PRODUCT.
CAUTION: KEEP FLOORS IN FRONT OF KETTLE WORK AREA CLEAN AND DRY. IF SPILLS OCCUR, CLEAN
IMMEDIATELY TO AvOID SLIPS OR FALLS.
WARNING: KEEP WATER AND SOLUTIONS OUT OF CONTROLS AND BURNERS. NEvER USE A HIGH
PRESSURE HOSE TO CLEAN KETTLE SURFACES.
CAUTION: MOST CLEANERS ARE HARMFUL TO THE SKIN, EYES, MUCOUS MEMBRANES AND CLOTHING.
TAKE PRECAUTIONS: WEAR RUBBER GLOvES, GOGGLES OR FACE SHIELD AND PROTECTIvE
CLOTHING. CAREFULLY READ WARNINGS AND FOLLOW DIRECTIONS ON CLEANER LABELS .
WARNING: DO NOT STAND ON OR APPLY UNNECESSARY WEIGHT OR PRESSURE ON THE KETTLE
FRONT OR POURING LIP. THIS COULD RESULT IN THE OvERLOAD AND FAILURE OF THE TILT
MECHANISM, AND POSSIBLE SERIOUS INjURY AND BURNS TO THE OPERATOR AND OTHERS.
NOTICE: NEvER LEAvE A SANITIzER IN CONTACT WITH STAINLESS STEEL SURFACES LONGER THAN 30
MINUTES. LONGER CONTACT CAN CAUSE CORROSION.
WARNING: FAILURE TO PERIODICALLY CHECK PRESSURE RELIEF vALvE OPERATION COULD RESULT IN
PERSONAL INjURY AND/OR DAMAGE TO EqUIPMENT.
WARNING: WHEN TESTING, AvOID EXPOSURE TO THE STEAM BLOWING OUT OF THE PRESSURE RELIEF
vALvE. DIRECT CONTACT COULD RESULT IN SEvERE BURNS.