A.J. Antunes & Co DCH-320 9500550 - Manual (Page 21)

21
DISPLAY CABINET HEATED
P/N 1010772 Rev. D 12/13
Item Part Description Qty.
No.
REPLACEMENT PARTS – DCH-300/320 (continued)
1 7000367 Front Glass Assy. 1
2 0020676 Inner Lamp Housing Weldment 1
0020675 Inner Lamp Housing Weldment
Mfg. No. 9500553
3 0010706 Resistor Assembly - 120V 1
0010644 Resistor Assembly - 230V 1
4 0502850 Housing, Lamp 1
0502895 Housing, Lamp
Mfg. No. 9500553
5 9020469 Display Rack (optional) 1
6 7000444 Sliding Door Assembly 2
7000975 DCH Mirrored Doors Replacement Kit 1
(Mfg. No. 9500551 ONLY)
7 0501869 Support, Center Pan 2
8 0504354 Crumb Tray 1
(Mfg No. 9500554 & 556 Only)
9 0501866 Water Tray 2
Except for Mfg No. 9500554 & 556)
10 0502172 Shield, Heat 3
11 0021317 Control Panel Weldment 1
12 7000346 Temperature Control Display,
150°F-165°F (66°C-74°C) 1
7000345 Temperature Control Display,
100°-165°F (38°-74°C) 1
13 4010151 Switch, Rocker 25A-125V 1
4010137 Switch, Rocker 25A-250V 1
14 0900143 Glass, Side 2
15 0020702 Heat Sink Assy. 1
16 4010199 Transformer 120VAC/12VAC 1
4010187 Transformer 230VAC/12VAC 1
17 7000652 Relay, Solid State 1
18 7000136 Terminal Block-3 Pole (Incl. #50 & 65) 1
19 4060341 Terminal Block-8 Pole 2
20 0504070 Glass Retainer (see Note 1)
21 0011717 Top Cap Assembly** RH (see Note 1) 1
0011718 Top Cap Assembly** LH (see Note 1) 1
22 2100185 Upper Door Track 1
23 2100186 Lower Door Track 1
24 0501946 Grill, Blower 1
25 0700451 Power Cord w/Plug, 1
NEMA 5-20P 120 V
0700453 Power Cord w/Plug, CEE 7/7 1
26 020K108* Gasket Kit, Bottom 1
27 0503976 Lamp, Bulkhead 1
29 4060360 Lampholder 8
30 4060359 Lamp, Night - 120V, 10 Watts 8
31 0900152 Display Panel (Black Outline) 1
0900181 Display Panel (Clear) 1
32 0900174 Transparency Holder 1
33 0900153 Diffuser Panel (white) 1
34 0501860 Frame, Display 1
35 400K123 Motor, Blower 120V Incl. #71 2
(Except Mfg. No. 9500554 & 556)
4000194 Blower Motor Mfg. No. 9500553 1
36 0200155 Magnetic Strip 2
37 5040028 Base Hinge Assy. 1
38 4030304 Heating Element, 120V, 500 Watts 3
4030239 Heating Element 230 Volts 825 Watts 3
39 7000369 Thermistor Kit 1
40 0501865 Duct Access Cover 1
41 0502556 Deflector, Heat 1
42 4060252 Bulb-Quartz Halogen 100W 2
43 4060189 Bulbholder, Quartz 4
44 0800229 Guard, Lamp 1
0800224 Guard, Lamp Mfg. No. 9500553
45 0502866 Cover, Lamp Bracket 2
48 040K251 Strain Relief Kit. 1
040K315 Strain Relief Kit (Mfg. # 9500553) 1
46 0502865 Bracket, Lamp Housing 2
50 306P101* Nut, Hex, #6-32, SS 1
51 306P105* Screw, #6-32 x 1/2, SS 1
52 306P130* Nut, Hex, KEPS, #6-32 1
53 308P103* Screw, #8-32 x 1/4, 6
54 308P124* Screw, #8-32 x 1/2, 1
55 308P127* Screw, #8-32 x 5/16, SS 1
56 308P143* Nut, Hex, KEPS, #8-32 1
57 308P144* Screw, #8-32 x 1/4, #6 Head 2
58 308P159* Thumbscrew, #8-32 x 11/32 1
59 310P146* Nut, Hex, KEPS, #10-32 1
60 310P110* Screw, #10-32 x 1/2, SS 4
61 310P123* Screw, #10-24 x 1/2, SS 1
62 040P111* Snap Bushing 2
63 308P105* Screw, #8-32 x 1/2, SS 2
64 308P151* Screw, #8-32 x 5/16” 1
65 306P123* Screw, #6-32 x 7/8” 1
66 2180179 Side Glass Nylon Stopper 1
67a 0021478 Pan Adapter Insert (Optional) 1
(slope version)
67b 002K897 Pan Adapter Insert (Optional) 1
(non-slope version)
69 0501966 Diffuser, Water Tray 2
70 213K103 Full size pan 2-1/2” deep (optional) 1
71 7000174 Blower Cage Bearing & Grommet Kit 1
(Except Mfg. No. 9500554 & 556)
Item Part Description Qty.
No.
* Only available in packages of 10
** LH/RH is determined by viewing front of curved glass panel.
NOTE 1: If the existing 2 Top Glass Retainers (item #20) ARE NOT rubber coated, it is recommended that you replace them along with
the 2 Top Cap Assemblies (item #21) with Glass Hardware Kit #7000368. This kit consists of:
• 2 rubber coated Glass Retainers (P/N 0504070)
• 1 Top Cap Assembly (RH) (P/N 0011717)
• 1 Top Cap Assembly (LH) (P/N 0011718)
• 2 Nylon Slide Side Glass Stoppers (P/N 2180179)
• 2 Thumbscrews (P/N 3080159)
• Installation Instructions (P/N 1010828)