New Buck Corporation 261 - Manual (Page 3)

TABLE OF CONTENTS
Important Instructions ……………………………………………………………………...…...2
SECTION I: Introduction………………………………………………………………………..3
Cautions………………………………………………………………………………………….5
SECTION II: Residential Freestanding Vertical Installation
.
………………..…………...…...6
Minimum Clearances / Floor Protection and Combustibles……………………………………. 6
Preparing Stove For Installation
..
………………………………………………………………..7
How to locate chimney exit, and install………………….…………………………………..…..8
A. Vertical Exit Using Single Wall Pipe /Listed 2100° UL 103 HT chimney
.. .
….…………...….8
B. Vertical Exit Using DVL Close Clearance Pipe /Listed 2100° UL 103 HT chimney
.
…...…10
C. Vertical Wall Exit Using Single Wall Pipe and Elbow /Listed 2100° UL 103 HT
Chimney and T-BOX assembly
. .
.………………………………………………...…………12
D. Vertical Wall Exit Using DVL Close Clearance Pipe ,and
Elbow /Listed 2100° UL 103 HT Chimney and T-BOX assembly
.
………………..……….14
E. Vertical Exit Into Masonry Flue Using Single Wall Pipe and Elbow..……………………..16
F. Vertical Exit Into Masonry Flue Using DVL Close Clearance Pipe and Elbow……..……..18
SECTION III: Residential Freestanding Rear Installation …………….…………………...….20
Minimum Clearances / Floor Protection and Combustibles ………………………………….. 20
Preparing Stove For Installation
. .
………………………………………………………...…….21
How to locate chimney exit, and install………………….………………………………....…..22
A. Rear Exit Into Masonry Flue Using Single Wall Pipe
..
…………………………………....
..
..22
B. Rear Exit Into Masonry Flue Using DVL Close Clearance Pipe
. .
…………………………..24
C. Rear Exit to Vertical then Horizontal DVL Close Clearance Pipe and Elbows
... .
…………....26
D. Rear Exit Into Masonry Fireplace using Single Wall Pipe ………....……………….……..28
SECTION IV: Alcove Installation Vertical or Horizontal exit ……………..……………….....30
Minimum Clearances /Floor Protection and Combustibles …………………………………....30
Preparing Stove For Installation
. .
………………………………………………………...…….31
How to locate chimney exit, and install………………….………………………………....…..32
(A) Vertical Installation using DVL Close Clearance Pipe.
1.Alcove Installation: Vertical Exit with standard close clearance shield and pipe shield …….32
2.Alcove Installation: Horizontal Exit with standard close clearance shield and pipe shield ….34
(B) Rear Installation using DVL Close Clearance Pipe.
1 Alcove Installation: Rear Exit with standard close clearance shield and pipe shield …..…...36
SECTION V: Freestanding Mobile Home Installation
.
…..…………………………………….39
Minimum Clearances /Floor Protection and Combustibles …………………………………...39
Preparing Stove For Installation
. .
………………………………………………………...…….40
Preparing Heater Location…….
. .
………………………………………………………...…….41
Minimum Clearances to Combustibles …………………………………………………...…...42
How to locate chimney exit, and install………………….………………………………....…..43
Wood Heater Safety
.
…………………………………………………………………...………46
Operation ……………………………………………………………………………...……….47
Troubleshooting
. .
……………………………………………………………………...………..48
LIMITED WARRANTY ……………………………………………………………...………50
1