Champion Power Equipment 92750 - Manual (Page 8)

5
REV 92750-20131216
ENGLISH 92750
SAFETy RULES
Training
1 . Read the Operator’s Manual completely before
attempting to use this log splitter .
2 . Do not allow anyone to operate your log splitter who
has not read the Operator’s Manual or has not been
instructed on the safe use of the log splitter .
3 . Never allow children or untrained adults to operate
this machine .
4 . Many accidents occur when more than one (1) person
operates the log splitter . If a helper is assisting in
loading logs to be split, never actuate controls until
helper is clear of the area .
5 . Never allow anyone to ride on the machine .
6 . Never transport cargo on the log splitter .
7 . High fluid pressures are developed in hydraulic
log splitters . Pressurized hydraulic fluid escaping
through a pin hole opening can puncture skin and
cause sever blood poisoning . Therefore, the following
instructions should be heeded at all times .
a . Do not operate the unit with frayed, kinked,
cracked or damaged hoses, fittings, or tubing .
b . Stop the engine and relieve hydraulic system
pressure before changing or adjusting fittings,
hoses, tubing, or other system components .
c . Do not adjust the pressure settings of the pump
or valve .
d . Do not check for leaks with your hand . Leaks
can be detected by passing cardboard or wood
over the suspected area . Look for discolouration .
If injured by escaping fluid, see a doctor at
once . Serious infection or reaction can develop
if proper medical treatment is not administered
immediately .
8 . Keep the operator zone and adjacent area clear for
safe, secure footing .
9 . If your log splitter is equipped with an internal-
combustion engine and intended for use near any
unimproved forest, brush, or grass covered land,
the engine exhaust should be equipped with a spark
arrestor . Make sure you comply with local, state,
and federal codes . Take appropriate fire-fighting
equipment with you .
10 . Log splitters should be used only for splitting
wood . Do not use for other purposes unless the
manufacturer provides attachments and instructions .
Preparation
1 . Be thoroughly familiar with all controls and with
proper use of the equipment .
2 . Safety Gear:
a . Always wear safety shoes or heavy boots when
operating the machine .
b . Always wear safety glasses or goggles when
operating the machine .
c . Never wear jewelry or loose-fitting clothing that
might become entangled in moving or rotating
parts of the machine .
3 . Make sure the splitter is on a level surface . Block
tires and ensure support leg is secure to prevent
unintended movement of the log splitter during
operation .
a . Always operate the splitter from the
manufacturer’s indicated operator zone .
4 . Logs to be split on ram-type units should be cut as
squarely as possible .
5 . Fuel:
a . Use an approved fuel container .
b . Never add fuel to a running or hot engine .
c . Fill fuel tank outdoors with extreme care . Never
fill fuel tank indoors .
d . Replace gasoline cap securely and clean up any
spilled fuel .