Sears 390.2521 - Manual (Page 2)

CONTENTS
INTRODUCTIONA''ARRAJSm’
PUMP PERFORMANCE
NL\JOR COMPONENTS
INSTALLATION
ELECTRICAL
OPERATION
MAINTENANCE
HELPFUL HINTS
TROUBLESHOOTING GLilDE
REPAIR PARTS
3
3
4-5
6-7
8-10
10
11
12-14
INTRODUCTION
Please read our instructions before mstalling and using your
Shallow VCeU 'VTater System This will help you obtain the
full benefits of the quality' and convenience built into this
equipment It will also help you avoid any needless service
expense resulting from causes bej'ond our control which are
not covered by our warranw
FULL ONE YEAR WARRANTY ON CRAFTSMAN*' WELL PUMP
For one year from üie date of purdiasc. Scars ~№111 rqmr or replace well рштф, free of chai^ if defective in material or'ЯогктапвЫр
UMITED WARRANTY ON CRAFTSMAN" PROFESSIONAL HYDRO-GLASS" WELL PUMP
After CHie year and Huougb th^ vears ftom Ac date of purchase. Scars wUl AimiA, ftec ofcharge, a replacement part for any delcaive part You pay labor
FULL FIVE YEAR WARRANTY ON CRAFTSMAN" CAPTIVE AIR TANK
For fo’c years from date of purchase. Sears wiH repair or replace Ae tank, free of charge, if defective in niattnal or workmanship
This warranty does not cover repairs or replacement parts necessary'because of Ausc or negligence, includb^ äüute to ¡падЧ, adjust and operate this pump
according to Ac Astnicäons in the owners manual.
UMITATION OF UABILITY
SEASS WILL /ЮГ BE LIABLE ГОД LOSS OR DAMAGE TO PROPERTY OR ANY INCnTENTAL OR CONSEQUENTIAL LOSS OR EXPENSE FROM PROPERTY
DAMAGE DUE DIRECTLY OR INDJRECILY FROM THE USE OF THIS PRWUCF.
Some states do not allow Ac cxiAislon or limitation of inddentai or cemsequenti^ damages, so the above limitation or exdusion may not apply to you
lK4Jtß4A7T SERVICE IS A VAHABLE BY SIMPLY CONTACTING THE NEARESTSEARS SERVICE CENTER/DEPARTMENT IN THE UNITED STATES
This warranty' apphes only while Als product is m Ae United Stues
This warranty gives you specific legal rights, and you may also have oAer rights which vaiy from state to state
Sears, Roebuck and Co., Dept 8I7WA Hofiman Estates, IL 60E79
READ AND FOLLOW SAFETY INSTRUCTIONS!
Carefully read and follow all safety instructions in this
manual or on pump.
This is the safety alert symbol. ''X'hen y ou see this
sjmbol on your pump or in this manual, look for one
of the foUovnng signal words and be alert to the potential
for personal m)uiy^'
A DANGER
w'ams about hazards that w'iU cause senous
personal mjury, death or major propeny' damage if ignored
A WARNING about hazards that will or can cause se­
nous personal injury', death or major property damage if ig­
nored
ik CAUTION ^ about hazards that will or can cause
minor personal mjury' or property' damage if ignored
The word NOTICE indicates special mstructions which are
important but not related to hazards
A CAUTION \totor normally operates at high temperature
and will be too hot to touch It is protected from heat dam­
age dunng operation by an automatic mtemal cutoff switch
Before handimg pump or motor, stop motor and allow to
cool for 20 minutes
1 To avoid nsk of senous bodily injury' and property dam­
age, read safety' instructions carefully before instalimg
pump
2 Follow local and/or national plumbing and elcctncal
codes when installing pump
3 Keep well covered while installing pump to prevent
leav'es and other debns from fallmg mto well, con-
tarmnatmg well and possibly' damagmg pump
4 Protect pump and piping system from freezmg Allowing
pump or water sy'stem to freeze could severely damage
pump and v'oids w'arranty'
A CAUTION jygver run pump dry Runnmg pump w ithout
water may' cause pump to ov'crheat, damagmg seal and pos­
sibly causing bums to persons handling pump Fill pump
w'lth w'ater before startmg
A WARNINGNe\'er run pump against closed discharge.
To do so can boil water inside pump, causing hazardous
pressure in unit, risk of explosion and possibly scalding
persons handling pump.
it WARNING I tp avoid serious injury and equip­
ment damage, limit system pressure to 100 pounds
per square inch (PSI) or below at all times. Over­
pressure can cause tank blowup; install relief valve
capable of passing full pump volume at 100 PSI.
Vi'ith a new' w'ell, test w ell for punty' before use Consult
local Health Department for procedure
A WARNING
Hazardous voltage. Can shock, bum.
cause death, or start fires.