Brinly LVS-33 BH PolyVAC System - Manual (Page 30)

L-1771-D
Y D E M E R N O I T I D N O C / E S U A C M E L B O R P
ENGINE FAILS TO START* Spark plug wire disconnected. Connect wire to spark plug.
Fuel tank empty, or stale fuel. Fill tank with fresh fuel.
Fuel shut-off valve closed. Open fuel shut-off valve.
Faulty spark plug. Clean, adjust gap or replace.
LOSS OF POWER OR ENGINE
RUNS ERRATIC*
Spark plug wire loose. Connect and tighten spark plug wire.
Unit running on CHOKE. Move choke lever to OFF position.
Blocked fuel line or stale fuel. Clean fuel line; fill tank with fresh fuel.
Water or dirt in fuel system.
Disconnect fuel line at carburetor to drain fuel
tank. Refill with fresh fuel.
Carburetor out of adjustment. Adjust carburetor.*
Dirty air cleaner. Service air cleaner.*
ENGINE OVERHEATS* Carburetor not adjusted properly. Adjust carburetor.*
Engine oil level low. Fill crankcase with proper oil.
Engine clogged with debris. Clean debris from the engine's cooling system.
TOO MUCH VIBRATION Loose parts/fasteners.
Stop engine immediately and disconnect the
spark plug wire. Tighten all nuts and bolts.
Debris built up on impeller. Clean impeller with scraper to remove debris.
damage to impeller. Replace impeller.
UNIT DOES NOT DISCHARGE
DEBRIS INTO CANOPY/BED
Hose clogged.
Stop engine immediately and disconnect spark
plug wire. Remove hose from deck adapter
and blower housing, and clean out inside of
hose. If clogging continues, grass/debri is too
wet. Wait for drier conditions.
Upper chute clogged.
Stop engine immediately and disconnect spark
plug wire. Clean inside of upper chute. If
clogging continues, grass/debri is too wet.
Wait for drier conditions.
Foreign object is lodged in impeller.
Stop engine immediately and disconnect spark
plug wire. Remove hose from blower housing
and remove lodged object. If object/debri is too
large, remove blower housing and remove
object/debris.
Engine is running too slow. Use engine at full throttle.
.t r a c y t p m E .l l u f s i ti n U
EXCESSIVE AMOUNT OF GRASS
LEAKS AT THE REAR OF UNIT Canopy is not tied down with the
bungee tie straps Connect both bungee tie straps to the bed per
instructions.
Flap at the rear of canopy is not lying
properly against the bed
Make sure the flap is lying inside the bed.
CANOPY WILL NOT STAY OPEN Gas spring not working properly.
Check gas spring for damage or wear; replace
if necessary.
Cable assembly is not connected to
the canopy. Connect cable assembly to the canopy per
instructions.
LOAD DOES NOT DUMP
CLEANLY Large amount of yard debris has
been collected. Drive tractor forward (a few feet) while unit is in
the dump position.
TROUBLESHOOTING
NOTE:
* - Refer to engine manual packed with your unit.
- For repairs beyond the minor adjustments listed above, please contact your nearest authorized service dealer.
ENGINE:
The engine is warranted by the manufacturer and can be serviced by any factory authorized service center. Refer to your
engine manual for warranty, service, and optional information.
30.