Permasteel TG-09P01-SB - Manual (Page 19)

16
Usage:
1) Read instructions before lighting.
2) Open the lid during lighting.
3) Simply place a lighted match between the coils on the end of the lighting
rod and hold next to the burner to ignite.
4) Push and turn the knob to “HI” position, make sure the burner lights
and stays lit.
5) Repeat steps 3-4 to light other burners.
6) Keep a spray bottle of soapy water near the gas supply valve and
check the connections before each use. Do not light the grill if odor
of gas is present, and call our service center at (888)-287-0735.

TO LIGHT THE SEARING BURNER OF THE GRILL:
1) Read instructions before lighting.
2) Turn all knobs to “OFF ” then open the tank valve. Always keep your face and
body as far from the grill as possible when lighting.
3) Open lid during lighting.
4) Push and turn searing burner knob slowly to “ HI ” position with left hand 2
seconds later. The built-in igniter will click and spark simultaneously to light the
burner once burner lights. Turn the control knob to “OFF ” and release the
button IMMEDIATELY if the burner does not light within 5 seconds. Wait 5
minutes for gas to dispel, then repeat the lighting procedure.
5) Follow match lighting instruction if burner can’t be lit after repeating 3-4 times.

TO LIGHT THE SEARING BURNER BY MATCH:
1) Read instructions before lighting.
2) Open the lid during lighting.
3) Push and turn the searing burner knobs slowly to “ HI” position, then release.
4) Light by match. Make sure the burner lights and stays lighted.
 FLAME CHARACTERISTICS:
1) Check for proper burner flame characteristics. Each burner is adjusted prior to
shipment; however, variations in the local gas supply may take subtle necessary
adjustments.
2) Burner flames should be blue and stable with small yellow tips, with no excessive
noise, or lifting. If any of these conditions exist call our customer service line. If
the flame is yellow, it indicates insufficient air. If the flame is noisy and tends to
lift away from the burner, it indicates too much air.
3) Small yellow tips are ok.
GRILL LIGHTING INSTRUCTION