Holland FW8 (XA-201) - Manual (Page 5)

5
FW8 (XA-201) FIFTH WHEEL
Trouble-Shooting Guide
Cause
1. The trailer may be too high; the
kingpin is not entering the locks
properly.
2. Locks are closed.
3. Excess accumulation of rust or
grime is interferring with lock
operation.
PROBLEM: Difficult to couple to trailer
Remedy
1. Chock trailer wheels. Then using LOW
GEAR, lower the trailer landing gear
until the bolster plate is aligned with
the fifth wheel, as shown in Figure 3.
2. Make sure the locks are open. To open
locks, slide the handle forward and
pull it out to the maximum extension.
The lock will swing to the open position
(see Figure 4). If the lock does not open,
hold the handle all the way out and
use a pry bar to rotate the lock into the
open position. Do not put your hands
or fingers on or near the lock jaw.
3. Thoroughly steam clean the fifth wheel
then relubricate all moving parts, as
described in Holland Service Bulletin
XL-SB41. Operate several times to work
in the lubricant. Follow recommended
lubrication schedule as detailed in
Service Bulletin XL-SB41.
OK
FIFTH WHEEL
MUST LIFT
TRAILER
➠
➠
FIFTH WHEEL
TILTED DOWN
4"- 6"
USE LOW
GEAR
FIFTH WHEEL
WILL NOT LIFT
TRAILER
Wrong
Figure 3
LOCK OPEN
POSITION
ACTUATING
FINGER
PULL OUT
ALL THE W
AY
SLIDE
FORWARD
TO OPEN LOCK
Figure 4