GE TR5451 User Manual
Warning, Installation and operation manual, Tr5000 series transient voltage surge suppressors
2020003701 (08/06)
Page 1 of 4
Installation and Operation Manual
TR5000 Series Transient Voltage Surge Suppressors
Model Types: TR5451 and TR5452
IMPORTANT NOTICE
THE ENTIRE CONTENT OF THIS INSTRUCTION MUST BE READ AND
FULLY UNDERSTOOD BEFORE ATTEMPTING ANY INSTALLATION
OR ENERGIZATION OF THE TVSS.
If the minimum requirements of this manual are not followed, the TVSS could become irreversibly damaged,
and/or the electrical system could be left unprotected. Failure to comply with the applicable requirements of
this instruction can void the TVSS warranty.
P
RODUCT
D
ESCRIPTION
:
GE TR5451 and TR5452 Model Transient Voltage Surge Suppressors (TVSS) are
designed for installation on low voltage electrical distribution systems, protecting electrical
equipment loads against the damaging effects of transient voltages
.
P
RE
-I
NSTALLATION REQUIREMENTS
:
Prior to installation of the TVSS, it is critical that the following items have been addressed.
D
O NOT ATTEMPT TO CONTINUE WITH THE INSTALLATION IF ALL OF THESE CONDITIONS HAVE NOT
BEEN MET
,
OR ARE UNKNOWN
.
Check the configuration and voltage supply ratings that will be feeding the TVSS
panel to ensure that the proper TVSS model number has been selected for your
SPECIAL ATTENTION MUST BE GIVEN TO VERIFY THAT A PROPER NEUTRAL-GROUND (XO) BOND
HAS BEEN MADE WHEN POWER IS SUPPLIED FROM AN UPSTREAM TRANSFORMER OR ANY OTHER
TYPE OF SEPARATELY DERIVED POWER SOURCE.
FAILURE TO PROVIDE THIS BOND, AS REQUIRED PER ARTICLE 250.30 OF THE NATIONAL ELECTRICAL
CODE, CAN RESULT IN ELEVATED PHASE TO GROUND SOURCE VOLTAGE POTENTIALS. THESE
VOLTAGES CAN CAUSE DAMAGE TO ELECTRICAL EQUIPMENT AS WELL AS SAFETY HAZARDS
INCLUDING FIRE, ELECTRICAL SHOCK, SERIOUS INJURY, OR DEATH.
THE EQUIPMENT COVERED BY THESE INSTRUCTIONS SHOULD BE INSTALLED AND SERVICED
ONLY BY COMPETENT PERSONNEL UTILIZING PROPER SAFETY PRACTICES AND PROCEDURES.
THESE INSTRUCTIONS ARE WRITTEN FOR SUCH PERSONNEL AND ARE NOT INTENDED AS A
SUBSTITUTE FOR ADEQUATE TRAINING AND EXPERIENCE IN SAFE PROCEDURES FOR THIS TYPE OF
EQUIPMENT.
P
P
O
O
W
W
E
E
R
R
M
M
U
U
S
S
T
T
B
B
E
E
P
P
R
R
O
O
V
V
E
E
N
N
D
D
I
I
S
S
C
C
O
O
N
N
N
N
E
E
C
C
T
T
E
E
D
D
B
B
E
E
F
F
O
O
R
R
E
E
S
S
T
T
A
A
R
R
T
T
I
I
N
N
G
G
I
I
N
N
S
S
T
T
A
A
L
L
L
L
A
A
T
T
I
I
O
O
N
N
,
,
I
I
N
N
S
S
P
P
E
E
C
C
T
T
I
I
O
O
N
N
O
O
R
R
M
M
A
A
I
I
N
N
T
T
E
E
N
N
A
A
N
N
C
C
E
E
!
!
F
F
A
A
I
I
L
L
U
U
R
R
E
E
T
T
O
O
D
D
O
O
S
S
O
O
M
M
A
A
Y
Y
C
C
A
A
U
U
S
S
E
E
S
S
E
E
R
R
I
I
O
O
U
U
S
S
I
I
N
N
J
J
U
U
R
R
Y
Y
,
,
D
D
E
E
A
A
T
T
H
H
A
A
N
N
D
D
/
/
O
O
R
R
P
P
R
R
O
O
P
P
E
E
R
R
T
T
Y
Y
D
D
A
A
M
M
A
A
G
G
E
E
.
.
WARNING
!